Install Instructions

FIGURE 2
Universal PVC Bracket
© Copyright 2011 Zoeller Co. All rights reserved.
FIGURE 5
OIL SMART
®
ALARM PANEL
WIRING DIAGRAM
SK2514
(RED)
POWER
120V INPUT
(BLUE)
TB1
TB1
132 4 5 687 9
OIL SMART ALARM PANEL
(WHITE) HOT NEUT OIL ALARM WATER COM
DRY CONTACTS
10 11
(GREEN)
OIL SMART
LIQUID ALARM SWITCH
®
®
FIGURE 1
Quick Mount Bracket
Assembly.
SK2560
Oil Smart
Liquid Alarm Switch
®
SK2547
FIGURE 3
CHECK VALVE
(RECOMMENDED)
GFCI
ALARM PANEL
GFCI
OIL SMART ALARM SYSTEM
SILENCE
WATER
R
TEST
OIL
QUICK MOUNT BRACKET
QUICK MOUNT BRACKET
PUMP (NONAUTOMATIC)
PUMP ON LEVEL
HIGH LIQUID LEVEL
ZOELLER
2" Min.
OIL SMART
LIQUID ALARM SWITCH
®
Typical Installation of Oil Smart
®
Pump
Switch and Alarm Panel.
FIGURE 4
PUMP (NONAUTOMATIC)
PUMP OFF LEVEL
ALARM PANEL
HIGH WATER LEVEL
PUMP ON LEVEL
OIL SMART LIQUID ALARM SWITCH
ABOVE WATER LINE
GFCI
GFCI
QUICK MOUNT BRACKET
CHECK VALVE
(RECOMMENDED)
OIL SMART ALARM SYSTEM
SILENCE
WATER
R
TEST
OIL
MINIMUM PIT
REQUIREMENTS
24" X 24"
QUICK MOUNT BRACKET
2" Min.
ZOELLER
®
SK2546
Typical Installation of Oil Smart
®
Pump
Switch and Alarm Panel.
Contact Manufacturer at, 3649 Cane Run Road, Lou is ville, Ken tucky 40211, Attention:
Cus tom er Ser vice De part ment to obtain any need ed repair or re place ment of part(s)
or additional in for ma tion pertaining to our warranty.
MANUFACTURER EXPRESSLY DIS CLAIMS LI A BIL I TY FOR SPE CIAL,
CON SE QUEN TIAL OR IN CI DEN TAL DAM AG ES OR BREACH OF EX PRESSED
OR IMPLIED WARRANTY; AND ANY IMPLIED WAR RAN TY OF FIT NESS FOR A
PAR TIC U LAR PUR POSE AND OF MER CHANT ABIL I TY SHALL BE LIM IT ED TO
THE DU RA TION OF THE EX PRESSED WAR RAN TY.
Some states do not allow limitations on the duration of an implied warranty, so the
above limitation may not apply to you. Some states do not allow the exclusion or
limitation of incidental or con se quen tial dam ag es, so the above lim i ta tion or exclusion
may not apply to you.
This warranty gives you specifi c legal rights and you may also have other rights which
vary from state to state.
Limited Warranty
Manufacturer warrants, to the purchaser and subsequent owner during
the warranty period, every new product to be free from defects in material
and workmanship under normal use and service, when properly used and
maintained, for a period of one year from date of purchase by the end user,
or 18 months from date of original manufacture of the product, whichever comes fi rst.
Parts that fail within the warranty period, one year from date of purchase by the end user,
or 18 months from the date of original manufacture of the product, whichever comes fi rst,
that inspections determine to be defective in material or workmanship, will be repaired,
replaced or remanufactured at Manufacturer's option, provided however, that by so
doing we will not be obligated to replace an entire assembly, the entire mechanism or
the complete unit. No allowance will be made for shipping charges, damages, labor
or other charges that may occur due to product failure, repair or replacement.
This warranty does not apply to and there shall be no warranty for any material or
product that has been disassembled without prior approval of Manufacturer, subjected
to misuse, misapplication, neglect, alteration, accident or act of God; that has not
been installed, operated or maintained in accordance with Manufacturer's installation
instructions; that has been exposed to outside substances including but not limited to
the following: sand, gravel, cement, mud, tar, hydrocarbons, hydrocarbon derivatives
(oil, gasoline, solvents, etc.), or other abrasive or corrosive substances, wash towels
or feminine sanitary products, etc. in all pumping applications. The warranty set out
in the paragraph above is in lieu of all other warranties expressed or implied; and we
do not authorize any representative or other person to assume for us any other liability
in connection with our products.
In those instances where damages are incurred as a result of an
alleged pump failure, the Homeowner must retain possession of
the pump for investigation purposes.
SK2386