Install Instructions

2
© Copyright 2010 Zoeller Co. All rights reserved.
Manufacturer warrants, to the purchaser and subsequent owner during
the warranty period, every new product to be free from defects in material
and workmanship under normal use and service, when properly used
and maintained, for a period of one year from date of purchase by the
end user, or 18 months from date of original manufacture of the product,
whichever comes fi rst. Parts that fail within the warranty period, one
year from date of purchase by the end user, or 18 months from the
date of original manufacture of the product, whichever comes fi rst, that
inspections determine to be defective in material or workmanship, will be
repaired, replaced or remanufactured at Manufacturer's option, provided
however, that by so doing we will not be obligated to replace an entire
assembly, the entire mechanism or the complete unit. No allowance
will be made for shipping charges, damages, labor or other charges
that may occur due to product failure, repair or replacement.
This warranty does not apply to and there shall be no warranty for
any material or product that has been disassembled without prior
approval of Manufacturer, subjected to misuse, misapplication, neglect,
alteration, accident or act of God; that has not been installed, operated or
maintained in accordance with Manufacturer's installation instructions;
that has been exposed to outside substances including but not limited
to the following: sand, gravel, cement, mud, tar, hydrocarbons,
hydrocarbon derivatives (oil, gasoline, solvents, etc.), or other abrasive
or corrosive substances, wash towels or feminine sanitary products,
etc. in all pumping applications. The warranty set out in the paragraph
above is in lieu of all other warranties expressed or implied; and we
do not authorize any representative or other person to assume for us
any other liability in connection with our products.
Contact Manufacturer at, 3649 Cane Run Road, Lou is ville, Ken tucky
40211, Attention: Cus tom er Ser vice De part ment to obtain any need ed
repair or re place ment of part(s) or additional in for ma tion pertaining
to our warranty.
MANUFACTURER EXPRESSLY DIS CLAIMS LI A BIL I TY FOR
SPE CIAL, CON SE QUEN TIAL OR IN CI DEN TAL DAM AG ES OR
BREACH OF EX PRESSED OR IMPLIED WARRANTY; AND
ANY IMPLIED WAR RAN TY OF FIT NESS FOR A PAR TIC U LAR
PUR POSE AND OF MER CHANT ABIL I TY SHALL BE LIM IT ED TO
THE DU RA TION OF THE EX PRESSED WAR RAN TY.
Some states do not allow limitations on the duration of an implied
warranty, so the above limitation may not apply to you. Some states
do not allow the exclusion or limitation of incidental or con se quen tial
dam ag es, so the above lim i ta tion or exclusion may not apply to you.
This warranty gives you specifi c legal rights and you may also have
other rights which vary from state to state.
Limited Warranty
Helpful Hints For Easy Installation
1. Read all instructions before beginning installation.
2. Be sure the fl oor is level within 1/8".
3. Install vent pipe seal with fl ange side of seal on
outside of lid.
4. Use soapy water to lubricate all seals to aid
in stal la tion.
5. Install rubber coupling/union in vent line to aid
dis as sem bly.
6. Do not over torque toilet mounting screws.
7. Do not use an automatic plumbing vent device.
8. Obtain model number and date code, and record
in for ma tion in the space provided on the front of
this manual. Refer to this information when calling
Fac to ry.
Do’s And Don't’s For Installing A Unit
1. DO read all installation material with the unit.
2. DO inspect unit for any visible damage caused
by shipping. Contact dealer if unit appears to be
damaged.
3. DO clean all visible debris from the unit.
4. DO always disconnect pump from power source before
han dling. DO always connect to a separately protected
and prop er ly grounded ground fault protected circuit.
DO NOT ever cut, splice or damage power cord. DO
NOT carry or lift pump by its power cord. DO NOT
use an extension cord.
5. DO install a ball or gate valve and a union in the
discharge line downstream of the check valve.
6. DO test pump immediately after installation to be sure
that the system is working properly.
7. DO review all applicable local and national codes
and verify that the installation conforms to each of
them.
8. We DO NOT recommend this product be connected
to utilities other than those found in a normal
bathroom application. Washing machines and
dishwashers are examples of equipment that we Do
Not recommend.
9. DO inspect and test system for proper operations at
least every 3 months.