Owner`s manual

General Operation
4.8
Add On Electrical Equipment
WARNING! Do not add electrical components to your
motorcycle unless approved by an approved Zero
Motorcycles dealer. Some add-on electrical components
can damage your motorcycle, prevent other components
from working as they should, and/or dramatically reduce
the range and/or life expectancy of the power pack.
Power Pack Charger
Keep your power pack connected to the charger when
your motorcycle is sitting in storage or if it will be sitting
unused for more than 30 days. The power pack must be
charged within 24 hours if fully discharged, and charged
within 90 days if stored fully charged. Zero recommends
you plug in your Zero Motorcycle after 30 days, even if fully
charged. Please leave your Zero Motorcycle plugged in
whenever possible.
WARNING! Only
charge the Zero power pack with the
Zero charger. The charger is located under the power
pack.
When charging the motorcycle’
s power pack, the charger
can be left ON, even after the power pack is fully charged.
There are two possible cases that can occur:
 When connected to the charger, the power pack will
receive a full charge. Once fully charged, the charger
will check the status of the power pack once every 72
hours to ensure that it maintains a full charge. When
fully charged, a green light will illuminate on the
charger. Should the charger not read that the power
pack is full, it will continue to attempt to fully charge the
power pack. In this event the green light may not
illuminate; however, the power pack may be fully
charged. To ensure that the power pack is charged,
check the charge indicator on the dash panel prior to
riding.
 If the powe
r pack terminates the charge before the
charger reaches the state previously mentioned, then
the charger will continue to cycle and will top off the
power pack until the power pack is removed from the
charger, or the charger reaches the complete state
previously noted.