OUTDOOR GAS GRILL INSTALLATION GUIDE
OU TDOOR GAS G RIL L Contents 2 Outdoor Gas Grill 3 Safety Precautions Important Note Product Information To ensure this product is installed and operated as safely Important product information including the model and serial number are listed on the product rating plate. For outdoor grills, the rating plate is located underside of the drip tray. The drip tray must be removed to view the rating plate.
SAFETY PRECAUTIONS IMPORTANT SAFEGUARDS • Wolf outdoor gas grills and modules are for outdoor use only. Do not install or operate in an enclosed area. BEFORE LIGHTING: • Read instructions before lighting. • Installation must be performed by a qualified installer, service agency or the gas supplier. • Open hood or remove cover before lighting. • Warranty service must be performed by Wolf factory certified service.
SP EC IFICATIONS Installation Requirements For built-in applications, Wolf outdoor grills and the burner module are designed for easy placement into a built-in enclosure. For outdoor grills, installation in a combustible enclosure requires an insulating liner. For the burner module, an insulating liner is not required. The enclosure should be built according to specifications for your specific installa-tion on page 6.
SP EC IFICATIONS Gas Supply G A S R AT I N G The outdoor grill must be connected to a regulated gas supply. The supply line must be equipped with an approved external gas shut-off valve located near the grill in an acces-sible location. Do not block access to the shut-off valve. Refer to the illustration below. A gas supply line of 19 mm rigid pipe must be provided to the outdoor grill or module. If local codes permit, a certified, .
SP ECIFICATION S Outdoor Grill Burner Module NON-COMBUSTIBLE INSTALLATION COMB U STI BLE INSTAL L AT IO N ACCE SSO RY D OO RS AND D RAW ER S 21 mm 21 mm GRILL OPENING DO O RS LINER OPENING COUNTER TO P O VERHANG COUNTER TO P O VERHANG 305 mm 64 mm 457 mm Single 762 mm Double 914 mm Double 1067 mm Double 1372 mm Double D R AWE RS 330 mm 616 mm 660 mm GRILL OVERLAP OPENING DEPTH 89 mm 152 mm G CL OPENING DEPTH 70 mm KNOCKOUT LINER OVERLAP 14 mm Single Drawer 2- or 3-Drawer Unit Drawe
INSTA LLATION Gas Supply Line NATURA L GAS CONNE CTION Install the natural gas pressure regulator supplied with the outdoor product with the arrow on the regulator pointing towards the unit. Refer to the illustrations below for a typical natural gas installation. LP GAS CO NNE CT IO N L P GAS S AF E T Y RE Q UIRE ME NT G A S L EA K TES TI N G For whole house LP gas connection, the Natural gas regulator can be converted for LP.
INSTA LLATION Installation Side Burner Installation P REPA RATION CART INSTA L L AT IO N Remove and recycle packing materials. Remove labels and protective plastic film from the grill. 1 Place briquette trays in the grill above the burners with flash tubes positioned at the front. Refer to the illustration below. Place burner grates directly above the briquette trays with square openings in the grates at the front.
INSTA LLATION Side Burner Installation INSTA LL SIDE BURNE R SHROUD 6 1 Side burner is placed inside shroud for shipping. Lift out to remove side burner from shroud. 2 Hang shroud by hand-starting four 10-32 machine screws provided through upper slots of shroud, into upper holes of cart. Do not fully tighten screws until shroud is properly aligned. Refer to the illustration below.
INSTA LLATION Side Burner Installation ELECTRICAL CONNE CTION 1 Depending on the serial number of the grill, there may be one or two connectors near the front of the grill just above the manifold. Locate the connectors by looking above the manifold near the front of the grill. 2 Remove the unpopulated connector housings from the wire harnesses coming from the grill as shown in the illustration below. 3 Attach the appropriate connector housing from the side burner to the grill.
TROU BLESHOOTING Troubleshooting IMPORTANT NOTE: If the outdoor gas grill does not operate properly, follow these troubleshooting steps: • Verify electrical power is supplied to the grill. • Verify proper gas supply. • Verify the gas supply shut-off valve is in the open position. • Check that control knobs are turned to the ON position and held in to active the igniters. • If the outdoor gas grill does not operate properly, contact Wolf factory certified service. Do not attempt to repair the grill.
Wolf Appliance International Limited Warranty FOR RESIDENTIAL USE These Warranty Terms and Conditions (‘Warranty’) constitute your agreement with Sub-Zero Group Australia Pty Ltd (ACN 610 807 899) (‘Wolf’) and will apply to your service order. The benefits given by this Warranty are in addition to all consumer guarantees and other rights and remedies prescribed by the Australian Consumer Law and any other applicable laws.
M F0 9 7