INSTALLATION GUIDE Gas Ranges
Contents Important Note Wolf Gas Ranges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 To ensure the safe and efficient use of Wolf equipment, please take note of the following types of highlighted information throughout this guide: Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Gas Range Specifications . . . . . . . . . . . . . . . . . . . . . . 5 Gas Range Installation . . . . . . . . . . . . . . . . . . . . . . . .
Wolf Gas Ranges 3 wolfappliance.com/specs Gas Range Installation IMPORTANT NOTE: This installation must be completed by a qualified installer, service agency or gas supplier. Wolf Gas Range Read this entire installation guide prior to installation and save for the local inspector’s reference. The homeowner should keep this installation guide for future reference.
Safety Instructions 4 IMPORTANT INSTRUCTIONS WHAT TO DO IF YOU SMELL GAS: If the information in this guide is not followed exactly, a fire or explosion may result, causing property damage, personal injury or death. • Do not try to light any appliance. • Do not touch any electrical switch. • Do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s • Installation and service must be performed by a qualified installer, service agency or the gas supplier.
Gas Range Specifications 5 wolfappliance.
Gas Range Specifications 6 Installation Requirements VENTILATION Failure to locate the range without the proper clearances will result in a fire hazard. IMPORTANT NOTE: Caution must be used in planning the proper installation of the Wolf gas range to avoid fires or damage to adjacent cabinetry or kitchen equipment. Follow all minimum clearances to combustible surfaces shown in the installation illustration for your specific model on the following pages.
Gas Range Specifications 7 wolfappliance.com/specs Electrical Requirements ELECTRICAL SHOCK HAZARD: Plug into a grounded 3-prong outlet. Do not remove ground prong. Do not use an adapter. Failure to follow these instructions can result in electric shock, fire or death. The Wolf gas range requires a 110/120 V AC, 50/60 Hz electrical supply to operate the electronic ignition system. The service should have its own 15 amp circuit breaker.
Gas Range Specifications 8 Gas Supply Requirements EXPLOSION HAZARD: Use a certified gas supply line and install a gas shut-off valve. Securely tighten all gas connections. Failure to follow these instructions can result in explosion, fire or death. IMPORTANT NOTE: The gas range must be connected to a regulated gas supply. IMPORTANT NOTE: This installation must conform with local codes and ordinances.
Gas Range Specifications 9 wolfappliance.com/specs Gas Supply Requirements GAS MANIFOLD PRESSURE • Natural Gas: Standard orifices are set for 5" (12.5 mb) WC. A natural gas pressure regulator is installed. • LP Gas: Standard orifices are set for 10" (25 mb) WC. An LP gas pressure regulator is installed. • Gas Supply Pressure: The maximum gas supply pressure to the regulator should never exceed 14" (34.9 mb) WC; .5 psi (3.5 kPa) for natural and LP gas. The minimum line pressure is 7" (17.
Gas Range Specifications 10 30" (762) Gas Range INSTALLATION SIDE CABINET 13" (330) 30" (762) TO 36" (914) max TO BOTTOM OF VENTILATION HOOD** 18" (457) min 6" (152) TO COMBUSTIBLE* 6" (152) TO COMBUSTIBLE* 30 1/4" (768) OPENING WIDTH 10" (254) 36" (914) FLOOR TO COUNTERTOP 37" (940) TO COOKING SURFACE 12" (305) 5 3/4" (146) 7 3/4" (197) E 2" (51) G 12" (305) LOCATION OF GAS AND ELECTRICAL EXTENDS ON FLOOR 5" 3" (127) (76) *Minimum clearance from rough opening to combustible materials
Gas Range Specifications 11 wolfappliance.
Gas Range Specifications 12 48" (1219) Gas Range INSTALLATION SIDE CABINET 13" (330) 30" (762) TO 36" (914) max TO BOTTOM OF VENTILATION HOOD** 18" (457) min 6" (152) TO COMBUSTIBLE* 6" (152) TO COMBUSTIBLE* 48 1/4" (1226) OPENING WIDTH 26" (660) 36" (914) FLOOR TO COUNTERTOP 37" (940) TO COOKING SURFACE 12" (305) 5 3/4" (146) 7 3/4" (197) E LOCATION OF GAS AND ELECTRICAL EXTENDS ON FLOOR 2" (51) G 12" 5" 3" (305) (127) (76) *Minimum clearance from rough opening to combustible materia
Gas Range Specifications 13 wolfappliance.
Gas Range Installation Anti-Tip Bracket Installation This range can tip. Injury to persons could result. Install the anti-tip bracket provided with the gas range. An anti-tip bracket is provided with the gas range. Install the anti-tip bracket a minimum of 6 1/2" (165) from the floor. If the range legs and casters are adjusted higher than the 3" (76) minimum, the anti-tip bracket must be mounted higher accordingly to engage the rear channel brace on the range.
Gas Range Installation 15 wolfappliance.com/specs Oven Door Removal IMPORTANT NOTE: Remove the oven door(s) only if it is necessary to fit the range through a tight doorway. Removal may cause damage to the porcelain oven interior or the door(s). Door removal should be done by a qualified service technician or installer. For removal, a hinge pin (supplied with the range) must be inserted in the appropriate hinge arm.
Gas Range Installation Oven Door Removal 16 Gas Supply Connection OVEN DOOR REINSTALLATION 1) Hold the oven door on both sides and position it with door hinges aligned with openings in the oven frame. 2) Holding the oven door at an approximate 30° angle from vertical, slide the hinges into the openings until the bottom hinge arms drop fully into the hinge receptacles. 3) Open the oven door to its fully opened position. Remove the hinge pin from the appropriate hinge arm.
Gas Range Installation 17 wolfappliance.com/specs Level the Range Verify Range Operation IMPORTANT NOTE: The top of the range must be level. Use both the adjustable front legs and the adjustable rear casters to level the range. IMPORTANT NOTE: Prior to operating the range, be sure to read the entire Wolf gas ranges use & care guide included with the range for important safety, service and warranty information.
Gas Range Installation Range Removal Unplug the range and disconnect the gas supply line before removing. If removal of the gas range is necessary for cleaning or service, shut off the gas supply. Unplug the range and disconnect the gas supply line. Remove the range. Reinstall in the reverse order and be sure to check gas connections for leaks. Refer to the Wolf gas ranges use & care guide for cleaning recommendations.
Service Information 19 wolfappliance.com/specs Service Information If service is necessary, maintain the quality built into your gas range by calling a Wolf authorized service center. To obtain the name and number of a Wolf authorized service center, check the contact & support section of our website, wolfappliance.com or call Wolf customer service at 800-332-9513. When calling for service, you will need the model and serial numbers of the gas range.
WOLF APPLIANCE, INC. P. O. BOX 44848 MADISON, WI 53744 816981 REV-A 8/ 2010 WOLFAPPLIANCE.COM 800.332.
