Installation Manual

v
CONFIDENTIAL UNDER NON-DISCLOSURE AGREEMENT (NDA)
Rev A1
Document:
WSS 4G Aircraft Installation Manual 750-
00003-00 Reva1.Docx
July -30
2020
4.3 ABR Chassis Installation ....................................................................... 37
5.0 SYSTEM INTERCONNECTS .......................................................................... 39
5.1 Connector List and Descriptions ........................................................... 39
5.1.1 ABR Front Panel ................................................................................... 40
5.1.2 RF Interconnects ................................................................................... 43
5.1.3 Power and Data Interconnects and Connectors .................................... 44
5.2 Connector Parts Lists and Construction ................................................ 46
5.2.1 ABR Power Input (P1-A) ...................................................................... 46
5.2.2 ABR Antenna Power Output (P1-B) ..................................................... 47
5.2.3 ABR Antenna Control Output (P2-A) .................................................... 49
5.2.4 Antenna Power & Control input – (FDQ P1) & (HPB P1) ..................... 50
5.2.5 ABR CWAP & Maintenance Eth. Outputs (P2-C & P2-D) .................... 51
6.0 POST INSTALLATION .................................................................................... 54
6.1 Installation Verification .......................................................................... 54
6.1.1 Post-installation Verification Instructions ............................................... 54
6.2 Ground Test .......................................................................................... 55
6.2.1 ABR Power On Self-Test (POST) ......................................................... 56
6.2.2 GPS Verification .................................................................................... 56
6.2.3 Service Activation .................................................................................. 56
6.2.4 System Traffic and Power tests ............................................................. 58
6.3 Flight Test ............................................................................................. 58
6.3.1 Flight Test Planning .............................................................................. 59
6.3.2 Flight Test Execution ............................................................................. 59
6.4 Operation and Maintenance .................................................................. 60
6.5 Recommendations for Eliminating Self-Wi-Fi Interference .................... 61
6.6 Router Configuration ............................................................................. 61
7.0 TROUBLESHOOTING AND FAULT DIAGNOSIS .......................................... 64
7.1 Product Support .................................................................................... 64
7.2 Troubleshooting Procedures ................................................................. 64
7.2.1 Diagnostic Access ................................................................................. 64
7.2.2 Aircraft Base Radio (ABR) Status Indicators ......................................... 64
7.2.3 Fault Indicators ...................................................................................... 66
7.2.4 Fault Conditions and Diagnosis Steps .................................................. 66
8.0 MAINTENANCE AND REPAIR ....................................................................... 70
8.1 General ................................................................................................. 70
8.2 Maintenance .......................................................................................... 70
8.3 Recommended Periodic Scheduled Servicing Tasks ............................ 70
8.4 Repair ................................................................................................... 70
8.5 Hardware & Software Updates .............................................................. 70