Service manual

nnn28 “UN-EXPECTED RESPONSE” ...............105
nnn29 “EXPECTED READING” ..................106
nnn30 “READER REBOOTED” ..................106
nnn31 “CALIBRATION IN RANGE” ...............106
nnn32 “NO RANDOM CHECK MK” (No random check MarK) . 106
nnn33 “UN-EXPECTED RANDOM CHECK” ...........106
nnn34 “PACK LARGER THAN SET” ...............106
nnn35 “PACK LESS THAN SET” .................106
nnn36 “GROUP NUMBER CHANGED IN SET”..........106
nnn37 “LAST SET SAME GROUP NUMBER” ..........106
nnn38 “MAX SHEETS IN ACCUM” (Maximum sheets in ......
ACCUMulator)............................106
nnn39 “UN-EXPECTED EOG” (End Of Group)..........106
nnn40 “NO RESPONSE TIMEOUT” ................106
nnn41 “BAD READ” (Bar Reading) ................106
nnn42 “MAX PAGE NOT = NO. PAGES” (Bar Reading) .....107
nnn43 “INVALID GROUP NUMBER” (Bar Reading) .......107
nnn44 “BAD CHECK DIGIT” (Bar Reading) ...........107
nnn45 “EXPECTED END OF SET” (Bar Reading) ........107
nnn46 “EXPECTED PAGE ZERO” (Bar Reading) ........107
nnn47 "PAGES GREATER THAN ACCUMULATOR MAX" ...107
nnn48 "BLANK PAGE OR MISSING MARKS" ..........107
nnn49 "ITEM VERIFY COUNT INVALID" .............107
nnn50 "READER SETUP ERROR" ................107
nnn51 "SETUP TIMEOUT ERROR" ................107
nnn52 "READLESS READ ERROR" ...............107
nnn53 "CUSTOMER ID CHANGED IN SET" ...........107
nnn54 "CUSTOMER ID DID NOT CHANGE AFTER LAST SET". 107
nnn55 "TOTAL PAGE CHANGED IN SET" ............107
nnn56 "SETUP TIMEOUT ERROR" ................108
nnn57 "NO READ DATA" .....................108
nnn99 "UNDEFINED ERROR" ...................108
C.3h (17xxx) Inserter Error Messages ............108
C.3i (19xxx) EngValue Error Messages .............108
C.3j (20xxx) EXITCOMM Error Messages ............108
20001 “NO MESSAGE RESPONSE” ...............108
C.3k (21xxx) InFeed Error Messages .............108
21001 “PAPER DEMAND TIMEOUT” ...............108
C.4 E-STOP PROBLEMS AND ANALYSIS ........108
C.4a Troubleshooting the E-stop / Interlock System .....108
Problem:...............................108
Some questions: ..........................108
Analysis: ..............................108
Troubleshooting V6-V6LT E-Stop/Gate Panel: ..........108
GBR 420 Inserter Screen List Diagnostic Description ....111
Overview: ...............................111
Inserter Setup Screen List Description of Pack Data: .......111
Inserter SetUp list Example:.....................112
420T V6LT OPERATOR & SERVICE MANUAL ISSUE 2009/06 Rev. 6/21/2011 TOC 6
071-33370-400
TABLE OF CONTENTS