Owner's manual

4
WEEKLY CLEANING & SANITIZING
Useaconcentratedcleaningsolutiontosimplifythecleaningprocedure.Thisprocedurerequiresaonegallon
containerofacleaningsolutioncontaininghotwaterandagranulatedconcentratedcleaner(acleanerlikeCoffee
DispenserCleanerCorporation#12580,
Urnexorequivalent)andaonegallon
container of clean hot water.
1. Turnonwatersupplytothedispenser.
2. Removethequickdisconnectfromthe
tea concentrate bag.
3. PulltheScholleconnectorfromthe
productdeliverytube(seedetail
drawing) and place the open line into
the container containing the cleaning
solution.
4. Placealargeemptycontainerunder
the dispenser faucet.
5. Openthefrontfaucetanddispenseat
least half of the cleaning solution.
6. Allow the dispenser to sit over night with the lines still
containingthecleaningsolution,beforeushing.
7. Flushthesystembyllingaonegalloncontainerwithcleanhot
water (no cleaning solution) and open the faucet and dispense at least
one gallon of the hot water or until all the cleaning solution has been
ushedfromthesystem.
8. RemovetheproductdeliverytubefromtheushingcontainerandreplacetheScholleconnectortotheendofthe
tube.
9. HookuptheproductdeliverytubeontotheBIBteaconcentrateanddispenseseveralcupstoprimethe
concentratelineoruntilconsistencyoftheproductiscorrect.
SANITIZING
UseaBag-in-Boxstylecleaningsolutiontosimplifythesanitizingprocedure.AproductlikeBevClean(http://bevclean.
com)beveragelinesanitizercomesina3gallonbag-in-boxthatconnectsdirectlytoyourbag-in-boxsystemforline
sanitizing.
1.RemovetheScholleconnectorfromtheteaconcentratebag.
2. PlacetheBIBsanitizercontainernexttotheTCCSteadispenser.Pullthespoutfromthesanitizerboxthrough
the markedarea.Removethecleartravelcapfromspout.Don’tworryaboutspillingsanitizerwhenthecapis
removed. The cap has an internal seal.
3. Thread the Scholle bag connector onto the bag spout.
5. Openthedispensingfaucetatthefrontofthedispenser.Whenyouseeclearliquidrunningfromthefaucet,stop
dispensing.
DONOTFLUSH.Allowthesanitizingsolutiontositinthetealinesovernightbeforeproceeding
withlineushingsteps6through8,below.
6. RemovetheScholleconnectorfromtheBIBcleanerandattachittotheteaconcentrateBIBproduct.
7. Openthedispensingfaucetandallowittorununtilyouseeteaowingfromthefaucet.
8. Repeattheprocessforalladditionalfaucetsondispenser.
Note:Muliti-outletmanifoldsareavailableforsanitizinguptoeightbeveragelineswithonebag-in-boxsanitizer.This
allowsyoutocleanallsystemsatonetime.