Manual

4
CLEANING & SANITIZING (PERFORM DAILY OR AS DIRECTED BY YOUR PRODUCT SUPPLIER)
Use a concentrated cleaning solution to simplify the cleaning procedure. This procedure requires a one gallon container of a cleaning solution
containing hot water and a granulated concentrated cleaner (a cleaner like Coffee Dispenser Cleaner Corporation #12580, Urnex or equivalent)
and a one gallon container of clean hot water.
1.Turnonwatersupplytothedispenser.
2.Removethequickdisconnectfrom
the tea concentrate bag.
3. PullthecapoffoftheQCD(seedetail
drawing) and place this end of the
line into the container containing the
cleaning solution.
4. Placealargeemptycontainerunder
the dispenser faucet.
5. Openthefrontfaucetanddispenseat
least half of the cleaning solution.
6. Allow the dispenser to sit overnight
beforeushingcleaningsolution.
7. Flushthesystembyllingaonegal-
lon container with clean hot water (no
cleaning solution) and open the faucet
and dispense at least one gallon of the hot water or until all the cleaning
solutionhasbeenushedfromthesystem.
8. RemovetheQCDfromtheushingcontainerandreplacethecap.Reconnect
theQCDtotheBagintheBoxteaconcentrateanddispenseseveralcupsto
primetheconcentratelineoruntilconsistencyoftheproductiscorrect.
SANITIZING
UseaBag-in-Boxstylecleaningsolutiontosimplifythesanitizingprocedure.AproductlikeBevClean(http://bevclean.
com)beveragelinesanitizercomesina3gallonbag-in-boxthatconnectsdirectlytoyourbag-in-boxsystemforline
sanitizing.
1.Removethequickdisconnectfromtheteaconcentratebag.
2. PlacetheBIBsanitizercontainernexttotheTCCteadispenser.Pullthespoutfromthesanitizerboxthrough
themarkedarea.Removethecleartravelcapfromspout.Don’tworryaboutspillingsanitizerwhenthecapis
removed. The cap has an internal seal.
3. SnaptheQCDbagconnectorontothebagspout.
4. Graspingthebagconnector(asshowninLoadProduct,step6),pushtheslidingprobeallthewayintothebag
spout.A“click”willbeheardwhenitisfullyinserted.
5. Oncethecleaningsolutionboxisconnected,openthedispensingvalveonthedispenserandrunliquidthrough
the valve until the sanitizer (clear liquid) is detected.
DONOTFLUSH.Allowthesanitizingsolutiontositinthetealinesovernightbeforeproceeding
withlineushingsteps6through8,below.
6. RemovetheQCDfromtheBIBcleaner.Unsnaptheconnectorprobe,pullingoutandremovingtheconnector
from the spout.
7. Flushthelinewithwarmwatertoremoveanycleaningsolution.
8. ReattachtheteaconcentrateBIBproduct.
9. Openthedispensingfaucetinfrontofthedispenserandallowwatertorunoutuntilteaowsfromthefaucet.
10. Repeattheprocessforanyadditionalfaucetsondispenser.
Note:Muliti-outletmanifoldsareavailableforsanitizinguptoeightbeveragelineswithonebag-in-boxsanitizer.This
allowsyoutocleanallsystemsatonetime.