Manual

10
SYMPTOM POSSIBLECAUSE SOLUTION
TROUBLESHOOTING GUIDE
Productowingfromthefaucet
istoofoamyorbubbly.
1.Reconnecttubingandtighten
clamps.
2.Makesurethebarbedendof
theQCDttingispushedin
on the hose and the clamp is
tight.
3.TurntheBIBsothetting
faces upward and open the
faucet until all the bubbles
are released.
4.ReplacethewornO-ringor
installanewQCD.
DOs and DON’Ts
INSTALLATION
1.Doconnectdispensertoalteredwaterline.
2.Doushltersbeforeconnectingtodispenser.
3.Dosamplenisheddrinkbeforemakingad-
justments.
4.Domakeveryslightdrinkadjustmentsthen
sample.
5.Don’tforgettoushltersbeforeinstallation.
6.Don’tmakeanypressureregulatoradjust-
mentsondispenser(DoNOTattemptto
adjust the regulator. If a regulator adjustment
isrequiredcallCURTISCARE).
7.Don’tforgettogetsampleapprovalfromcus-
tomer.
OPERATION
1.Dofullyactivatefaucethandlewhendispens-
ing drinks.
2.Doclean&sanitizedispensingassembly
monthly.
3.Dokeepdispenserprimedwithconcentrateat
all times.
4.Doreloadimmediatelywhenoutofconcen-
trate.
5.Doushandcleanlinesregularly.
6.Don’tforgettoclean&sanitizefaucetseatcup
7.Dofollowallcleaningandsanitizingproce-
dures.Removeandstoreteaconcentrateif
dispenser will not be used for an extended
periodoftime(morethantwodays).
1. The clamps at the check
valvemaynotbetight.
2. TheclampontheQCD
connectormaybeloose.
3. Tea concentrate product
mayhaveairintheBIB.
4.TheO-ringontheQCDis
worn out.