User Manual

3
MIXING VALVE ADJUSTMENT:
Forcustomerswhowishtoadjusttheavorofthedrink,themixingvalvechangesthewaterto
concentrateratio.Thisvalveisverysensitive.Onlyslightrotationofthemixingrodisneeded
tochangetheratio(1/16thto1/8thofaturn).Thestandardsetup,astheunitcomesfromthe
factory,isapproximately7:1ratio,whichwillgiveyoua5to8percentbrixbasedonthesweet
tea concentrate.
1.Toadjustthevalve,tiltthedispenseronit’sside.
2. Look underneath the unit and locate the adjusting rod.
3. Turn counter-clockwise for stronger drink – turn clockwise for weaker drink. Taste the tea
witheachadjustmenttodeterminethedesiredconsistency.
CAUTION–Donotrotateadjustingrodmorethan2fullturnsfromclosedposition.Moreturnswillcausethe
adjustment rod to disengage from the mixing valve, with a resulting leak.
CLEANING
STRAINER CLEAN-OUT
1. Turnoffthewaterowrunningfromthefacilitytothestrainer.
2. Useplierstograbthehousingofthestrainerandwithanadjustablewrench,removethecap.
3. Takeoutthewirestrainerandcleanoutthecontents.Useaspiralbristledbrushtocleaninsidethestrainer.
4. Rinse the strainer and replace it into the housing.
5. Return the cap to the housing and turn on the water line.
DAILY CLEANING
RegularcleaningoftheTCCNteadispenserisessentialinmaintainingthehighestqualityicedteayourequipmentis
capableofproducing.Prepareamildcleaningsolutionofdishwashingdetergentandwarmwater.
1. Wipeanyspills,dustordebrisfromtheexteriorsurfaces,withadampcloth.Applyastainlesssteelpolishto
prevent scratches.
2.Turnoffwatersupplyatvalvebehindunit.
3.Openthedispensingfaucettorelievepressureinthedispensinglines.
4. Remove the top cover and clean with the cleaning solution.
5.Cleanthefaucetassembly.
  a. Removethehandle/seatcupassemblyfromthefaucetbyholdingthebonnetandunscrewing.
  b. Cleanthefaucetcapandsiliconeseatcupassembly.
  c. Useaspiralbrushsoakedincleaningsolutiontocleaninsidethefaucetbody.
  d. Runthebrushthroughtheadapteronthebodyofthedispenser.
6.Rinseanddrypartsthatwereremoved.Assemblethedrypartsontotheunit.
WEEKLY CLEANING & SANITIZING
Useaconcentratedcleaningsolutiontosimplifythecleaningprocedure.Thisprocedurerequiresaonegallon
containerofacleaningsolutioncontaininghotwaterandagranulatedconcentratedcleaner(acleanerlikeCoffee
DispenserCleanerCorporation#12580,Urnexorequivalent)andaonegalloncontainerofcleanhotwater.
1. Turnonwatersupplytothedispenser.
2. Remove the quick disconnect from the tea concentrate bag.
3. PullthecapoffoftheQCD(seedetaildrawing)andplacethisendofthelineintothecontainercontainingthe
cleaning solution.
4. Placealargeemptycontainerunderthedispenserfaucet.
5. Openthefrontfaucetanddispenseatleasthalfofthecleaningsolution.