Owner's manual

4
I. Instructions for replacing a valve:
A. Shutoffthewaterlinerunningintotheunit.
B. Disconnectthepowercordorturnofftheunitatthetoggleswitchbehindtheunit.
C. Drainapproximately½to¾gallonofwaterfromthetanktoinsurethatthewaterlevelisbelowthe
levelofthevalves.Removethewiresandwatertubingfromthedefectivevalveandpullitfromthe
siliconetting.
D. Beforeinstallingonthetank,makeaninitialadjustmentwiththevalveoffofthetank.
 1. Loosenthescrewonthemetalguard.Rotateawayfromtheadjustmentscrew(g.1.).
 2. Carefully,turnowadjustmentscrewclockwiseallthewayin(seegure2.).Observerestrictor 
 position.Donotovertighten.
 3. Nowturntheowadjustmentscrewcounterclockwisethree[3]turns(or1½turnsfromthefully 
 openposition).
 4. Replacethemetalguard.
 5. Installthevalveonthetank,attachingwiresandsiliconetube.Pressthevalvefullyintothe 
 ttingontheheatingtank.
II. Dump valve, water ow adjustment:
  TheWaterowispresettoensureoptimummixingandproperchamberrinsing.Thevalvescurrentlyinstalledonyourunithavebeenset
  atthefactoryandshouldnotrequireadjusting.Thefactoryowratesettingis4oz.ofwaterin10seconds(or0.4oz./sec.).
Dump Valve Replacement
We recommend that you regulate the water ow in the valve ONLY when replacing a valve.
WARNING:Aswithallelectricalequipment,cautionmustbetakentoavoidelectricalshock.Be
surethepowercordisdisconnectedbeforeremovingcomponents.Thefollowingstepswillalso
involveworkingnearhotsurfaces.
COVER,TOPHEATINGTANKGENUSE
GASKET,TANKLID
KIT,PROBEWTRLVLW/FITTING,O’RING,NUT
DUMPVALVE120V12W
HEATINGELEMENT1600W120VW/JMNUT
SENSOR,TEMPERATURETANK
SWITCH,#4680VESSELLIMIT
TANKCOMPLETE,CAFEPC3
KIT,INLETVALVEREPAIRUSEONWC-826L
COVER,TOPCAFEPC3
CANISTERASSY4LBCAFEPC2/3/4
ELBOW,CANISTER3-WAY
COVER,DUMPVALVE
GEAR,PLASTIC
CONNECTOR,ORIFICEWATER
ELBOW,DISPENSECAFEOATS
BULKHEAD,WATERFITTING
TUBE,DISPENSEHOTWATER
LEG,ADJUSTABLEBLACK
TRANSFORMER,120VAC-12VAC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
15A
16
17
18
19
WC-5853-102
WC-43062*
WC-5502-01*
WC-3734*
WC-904-04*
WC-1438-101*
WC-521*
WC-6291
WC-3765L*
WC-7389
CA-1111-06
CA-1168
WC-58142
CA-1036*
CA-1095
WC-66086**
CA-1011-05
WC-53136
WC-3504*
WC-718
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
WC-782*
WC-37174*
CA-1135
WC-5310*
WC-68219
WC-68218
WC-722K
WC-39554
WC-66033
WC-66036-101
WC-826L*
WC-102*
WC-68211
WC-37266
WC-2627
WC-37365
WC-4394
CA-1136
WC-39872
CONTROLPOWERMODULECAFEPC’s120V
KIT,GEARMOTOR&GEAR
LATCHASSEMBLYDOORSIDEMOUNT
TUBING,5/16”IDx1/8”WSILICONE
COVER,BACKDOOR
DOOR,CAFEPC
PANEL,SW120VCAFEPC3(W/SMARTCARD)
LABEL,CONTROLPANELCAFEPC3
SCREEN,DRIPTRAYCAFEPC3
DRIP,TRAYASSYCAFEOAT3
VALVE,INLET1GPM120V10W
SWITCH,TOGGLENON-LIT25A120/240VAC
COVER,SIDELEFTCAFE3OAT
KIT,TANKOVERFLOWFITTINGWITHBUSHING
BUSHING,CONICALGENERALUSE
KIT,TANKINLETFITTINGINCLUDESBUSHING
GUARD,SHOCKHEATINGELEMENT
HINGE,ASSYPLASTICCAFEPC/SD2
LABEL,GRAPHICADHESIVECURTIS
*SuggestedPartstoStock
ITEM
№
PART
№ DESCRIPTION
ITEM
№
PART
№ DESCRIPTION
Illustrated Parts List
**UsedOnMachinesBuiltAfter8/2012.