TM Autococker® Marker Manual Worr Game Products 252 Granite Street • Corona, CA 92879 800.755.5061 • 909.520.9699 www.worr.com www.wgpchat.
WORR GAME PRODUCTS, INC. AUTOCOCKER® OWNERS MANUAL TM WORR GAME PRODUCTS, INC. 252 Granite Street Corona, Ca 92879-1283 Tel: (909) 520-9969 Toll Free: (800) 755-5061 Fax: (909) 520-9699 WARNING. This is not a toy. Misuse may cause serious injury or death. Eye protection designed specifically for paintball must be worn by the user and persons within range. Recommend 18 years or older to purchase. Persons under 18 must have adult supervision. READ OWNERʼS MANUAL BEFORE USING.
Autococker® Marker Manual Table of Contents Table of Contents I. Introduction II. Safety and Handling III. Safety Tips IV. Preparing for Usage V. Velocity VI. Timing VII. Cleaning Your Marker ----VIII. Autococker® Marker Schematic Notes Troubleshooting IX. F.A.Q. X. Lifetime Limited Warranty --- Warranty Card Colors and parts may vary from illustrations. Worr Game Products reserves the right to change parts at any time.
Autococker® Marker Manual TM Bud Orr has been revolutionizing the world of paintball since 1985. This unassuming gentle giant is quite possibly the single most influential innovator in the paintball industry. Interestingly enough, Budʼs contributions might never have happened, were it not for his daughter. After having been introduced to the sport by his daughter Lynne, Bud was able to incorporate his knowledge of mechanics with his newfound passion for the sport of paintball.
Autococker® Marker Manual DC-9 airplane tail) of double 2.5oz CO2 cartridges, which gave him over 200 shots between air changes. A feat that at the time was unheard of. By todayʼs standards this may not seem like a big deal, however in the early days of paintball the average marker would be lucky to offer 15 shots. Budʼs innovative ideas and unique customizing drew much attention from the other players at his home field.
Autococker® Marker Manual Notes -----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
Autococker® Marker Manual II. Safety and Handling Your Autococker® Marker is not a toy. It should be used only by adults or with adult supervision. Respect other peoplesʼ property and when using the Autococker® Marker, obey all local, state and federal laws. When entering a paintball field, become aware of their rules and regulations. It is very important to have the proper paintball protection before going to the paintball field for play.
Autococker® Marker Manual III. Safety Tips • Treat every marker as if it were loaded. • Never look down the barrel of a paintball marker. • Keep your finger off the trigger until ready to shoot. • Never shoot a person not wearing proper protection. • Never point the marker at anything you donʼt wish to shoot. • Keep the marker on safe until ready to shoot. • Keep the barrel blocking device in/on the markerʼs muzzle when not shooting. • Always remove paintballs and propellant source before disassembly.
Autococker® Marker Manual IV. Preparing for Usage 1. Screw barrel onto marker 2. Place barrel blocking device properly onto the marker CAUTION: Always wear paintball approved eye and face protection when dealing with a pressurized paintball marker. 3. Pull the cocking rod back until it latches into place 4. Connect the air source to the ASA (air system adapter.
Autococker® Marker Manual V. Velocity • Paintball industry approved protective gear (for face and eyes) must be worn at all times while operating and performing adjustments on this marker. • Do not insert objects into the space between the cocking block and the main body of the marker at any point in time. Improper marker treatment may result in damage to the marker and serious injury to the operator.
Autococker® Marker Manual VI. Timing Note: Always make sure you and everyone around you (200 yards) wears paintball approved eye and face protection. Your Autococker® Marker was thoroughly inspected and test-fired at the factory and should only require verifying the velocity adjustment with a chronograph before use. After extended use and under varying conditions, your Autococker® Marker may require some adjustment.
Autococker® Marker Manual Note: Your 04 Autococker® comes with an adjustable front regulator. This regulator controls the cocking pressure that flows through the 3-way and ram. Adjustment should be done in quarter turn increments. This regulator does not control the velocity of your paintball marker. Under no circumstances should you disassemble the regulator. VII.
Autococker® Marker Manual Notes -----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
™ Right Side
CAUTION: Before repairing or cleaning your marker, always remove barrel and gas cylinder. Then depressurize your marker by pointing in safe direction and dry-firing. ©2004 Worr Game Products Inc. All rights reserved.Parts & colors may vary without notice.
Autococker® Marker Manual Notes -----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
Autococker® Marker Manual VIII. Troubleshooting P US H P US H ON SAFE TY SAFE TY SAFETY Note: A qualified technician should make all repairs and adjustments. Do not attempt to perform any factory-only repairs. Send the marker to the factory or an authorized repair center. Any damage caused by improper adjustments is not covered by the warranty. Call Worr Game Products for further information. OFF 1. Marker will not fire after left in the sun or a hot place with bottle attached.
Autococker® Marker Manual 3. Marker will not fire when trigger is pulled. • Gas source pressure low or tank empty. Fill tank. • Ensure inline regulator is adjusted to correct operating pressure. • Marker may be over-timed. See “Timing.” 4. Marker will not cock or cocks every other time or less. • Pressure too low. Fill bottle or adjust regulator. • Front regulator pressure set too low. • Timing lug out of adjustment. • Velocity adjustment set too high. • Back block or cocking rod adjustment incorrect.
Autococker® Marker Manual 9. Low velocity. • Gas source pressure too low or tank empty. Fill tank. • Improper IVG adjustment. Adjust velocity. • Regulator pressure too low or high. • Check gas source. Make sure input pressure to marker is consistent. • Paint rolling down the barrel. Paint too small. • Bolt upside down. 10. Gas leaks down the barrel. • Remove and replace exhaust valve. 11. Marker fires and block comes back but wont go completely forward; locks approximately halfway.
Autococker® Marker Manual IX. F.A.Q. Q) Iʼm pulling the trigger and the marker is firing but the balls are not coming out or they are only going 5-10 feet. What do I do? A) Make sure the hole in your firing bolt is facing down. Also make sure your velocity adjuster is not screwed in more than 6 threads. Cheack to make sure your air bottle is not empty. Q) My gun is leaking out of the barrel. What do I do? A) Make sure your velocity adjuster is not screwed in more than 6 threads.
Autococker® Marker Manual Q) Can I make my mechanical Autococker® marker into an electronic Autococker® marker? A) Yes, WGP produces the Worrblade kit, which is an electronic trigger frame upgrade kit that will fit on any vertical Autococker® so you can take your game play to the next level. For more info go to www.worr.com or call Worr Games at (800) 755-5061. Q) Can I get my marker anodized a different color? A) Yes, WGP can custom anodize your Worr Game Products Autococker® marker to many custom colors.
Autococker® Marker Manual X. Lifetime Limited Warranty Worr Games Products, Inc. warrants that your Autococker®‚ marker will be free from defects in materials and workmanship. Any product determined by WGP to be defective in materials or workmanship in accordance with the above warranty will be repaired or replaced, at the option of WGP, free of charge when received at the factory freight prepaid, together with proof of purchase. This warranty is expressly in lieu of all other warranties.
Please fill out Warranty Card on other side and mail in to Worr Game Products with your receipt.
Attention Warranty Service Worr Game Products Warranty Registration Card Autococker® Serial # Name Address City State Zip Phone Purchased Date Purchased From ( )Dealer E-mail ( ) Distributor Country ( )Mail Order ( ) Other Please fill out this warranty card and mail with a photocopy of your purchase receipt to: Worr Game Products 252 Granite Street Corona, CA 92879 Please take a moment to fill out a brief questionnaire. Thank You.
Autococker® Marker Manual Quality Products from WGP SINCE 1985 The Sniper pump marker is the best option for the player who is trying to fine-tune their marksmanship skills. Whether an experienced player, or an unexperienced beginner this marker will definitely improve your game. The all new “Pro Stock” Autococker® Marker is the perfect option for the player of any skill level. The markers offers the WGP quality you have grown to love, not to mention the performance, for only a fraction of the price.
Autococker® Marker Manual Introducing the new Worrblade Electronic Upgrade Kit from WGP. Now you can have it all speed, accuracy, and support on both sides of the globe all in the same package! The most accurate marker in the world the Autococker® Marker combined with the Worrblade gives Recreational and Tournament playersʼ unprecedented firepower.
Autococker® Marker Manual Worr Games Products T-shirts & Hats “Traditional” Available in: Red & Black “Speed” S-3X “High School” S-3X “Flaming W” “Blocks” S-3X Available in: Red, Black & Blue “Multiply” S-3X “Torn” S-3X TM Page 25
Autococker® Marker Manual Ofspray Night vision M3 Tactical Light Play at night just as easily as the day. This high powered flash light will illuminate any situation. Infrared Illuminator Enhances your night vision. Tactical Rail System With long and short rails, you can accommodate almost any aftermarket accessories.
TM Worr Game Products Worr Game Products U.S.A. Europe 252 Granite Street Corona, CA 92879 Langenberger Str. 9, Tor 6, 40233 Duesseldorf, Germany P: 909.520.9969 F: 909.520.9699 www.worr.com www.wgppress.com P: +49 211 73 33 155 F: +49 211 73 33 150 www.worr-europe.com www.wgppress.
