Operator`s manual

+ 12 vIX
r- -,
1 ; C.B.
:( :20.1,
. ,
r "
I : EMERGENCY
L JSTOf> SW.
r 1
: lSToPSw.
l "
r
,
7.6MINIBTD
Schematic Diagram #39284
page 2
00
GLOWP!.UGS
:,'( 1 c.s .
I IDA
-
I (PREHEAT SW.
L _
L--+--+-_-( P
EXHAUST TEMP.
SWITC"
WATER
TEMP-SWITCH
OIL PIIESS.
SWITCH
•
"
rU'EL SOL.
o
STARTING AND STOPPING INSTRUCTIONS
START, I. ALWATS PUS" Pll(oE:AT SWITCH riIlST. HOLD fOR I!> TO '0 SECOtlOS AS REQUIRfO.
2: WI1ILE COtlTltII,IlNG TO PUSH PRE~AT SWITCH, PUSH START SWITCH.
3. WHEN GENERATOR SlAlfTS, RELEASE START SWITCH OtILY,
...... HEtI OIL Pl!£SSURE REACHES APPROXIMATELY 201'S1, RELEASE "IlEHEAT SWITCIi.(TI1E PREI1EAT
SWITCI1 OVERRlOES THE LOW O1L PRESSURE SI1UT DOWN CIRCUIT~
STOP: I. PUSH lotiO HOLD THE SToP SWITel1 UtlTIL GENERATOII STO~ COldPLETELY,
NOTES,
I. "HIS PRO~UCT IS Pl'IOT[CTEO BY A IotAtlUA\. RESET CIIiCUIT I!R'EAKER LOCATED tI( .... 1I THE SUIITEP 1."10 AS
CLOSE TO THf eURIIEtlT SOURCE AS POSSIBLE EXCESSIVE CURREtlT DRAW ANYWI1ERE IN TI<E
ItiSTRUMENT PAtlEL, WIIIlNG. 011 ENGINE WILL CAUSE THE SREAKEiI TO TIIIP. IN THIS (VENT "'OST
GEtlERATORS WILL SHUT DOWN BECAUSE THE OPENED BREAKlR OISCOtlN(CTS THE ruEL SUPPLY,
T>lEREFOIlE
THE O .... NER/BUILOER IotUST SE SUIIE THAT THE 'NSTRUIoIEtI~ PANEL ..... '1111'110. AND ENGINE
"liE lWST"LLEO TO PIIEVENT CONTACT BETWEEN ELECTRICAL DEVICES "NO SAL! WATER,
z. AN em-OFF SWITCH SHOULD BE INST"LLED IN TI115 CIRCUIT TO O1SCONNECT THE STAI'ITEII rl;Olool T .. r
BA11EI'IY IN AN EldERGENCY AND WHEN LE"VING HIE BOAT. TWELVE VOLT DIESEL ENG!tlE STARTERS
TYPICALLT OIlAW
200 10 300 "1001~ WHEN CRANKIN!>. THE OURATION Of INQiVIDUAL CRAN~ING CYCLES
SHOULD NOT EXCEEO
~O SECONOS_" SW'TeH WITH A CONTINUOUS IIATING or 17~ A",ps AT \2 vOC HILL
NOl'lloiALLT SERVE THIS F"\.INCTION, BU1 A SWITCH MUST NEVER eE USED TO ·~Af(E-THE ST/l.RHR
CIIICUIT.
WESTERBEKE GENERATORS
40