WELLS BLOOMFIELD, LLC 10 Sunnen Dr., St. Louis, MO 63143 telephone: 314-678-6314 fax: 314-781-2714 www.wellsbloomfield.
LIMITED WARRANTY STATEMENT are based upon the limitations in this warranty. Seller’s obligation under this warranty is limited to the repair of defects without charge by a Wells Bloomfield factory authorized service agency or one of its sub-service agencies. This service will be provided on customer’s premises for non-portable models. Portable models (a device with a cord and plug) must be taken or shipped to the closest authorized service agency, transportation charges prepaid, for service.
TABLE OF CONTENTS WARRANTY FEATURES & OPERATING CONTROLS PRECAUTIONS & GENERAL INFORMATION AGENCY LISTING INFORMATION INSTALLATION OPERATION MAINTENANCE INSTRUCTIONS CLEANING INSTRUCTIONS TROUBLESHOOTING SUGGESTIONS EXPLODED VIEW & PARTS LIST WIRING DIAGRAM PARTS & SERVICE CUSTOMER SERVICE DATA xi 2 3 3 4 6 7 8 10 11 14 16 17 INTRODUCTION Thank You for purchasing this Wells Bloomfield appliance. M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw.
FEATURES & OPERATING CONTROLS A. INFINITE SWITCH 1. On INFINITE SWITCH controlled warmers, power is applied to the heating element based on the control knob position, which varies the duty cycle of the heating element. 3. On warmers equipped with an indicator light, the light will glow when the infinite switch is in any position other than OFF. 4. The TEMPERATURE CONTROL KNOB will rotate without stopping, with PREHEAT and OFF having obvious detents. The OFF position is a “positive” OFF (i.e.
PRECAUTIONS AND GENERAL INFORMATION This appliance is intended for use in commercial establishments only. This appliance is intended to hold pre-heated food for human consumption. No other use is recommended or authorized by the manufacturer or its agents. Operators of this appliance must be familiar with the appliance use, limitations and associated restrictions. Operating instructions must be read and understood by all persons using or installing this appliance.
INSTALLATION WARNING: Risk of injury Installation procedures must be performed by a qualified technician with full knowledge of all applicable electrical and plumbing codes. Failure can result in personal injury and property damage. CAUTION FIRE HAZARD Avoid storing flammable or combustible materials in, on or near the appliance.
INSTALLATION 4. For “bottom-mounted” warmers (i.e. warmers mounted to a formed flange from underneath the counter top), apply a bead of food-grade silicone sealant to the top inside lip of the pan prior to attaching to the counter flange. 4. For “top-mounted” warmers (i.e. warmers mounted from above the counter top): a. Verify that provided sealants are applied to the underside of the warmer top flange prior to setting the unit into the cutout. b.
OPERATION Hot Surface Exposed surfaces can be hot to the touch and may cause burns. CAUTION: Shock Hazard DO NOT splash or pour water onto control panel or wiring. Always use an inset. DO NOT place food directly into the warmer. Always pour hot water into the warmer before it is preheated. DO NOT pour water into a dry, heated warmer. This may damage the unit. DO NOT put ice into a warmer pan. This will cause condensation on the inside of the warmer. Damage caused by condensation is NOT covered by warranty.
MAINTENANCE INSTRUCTIONS CARE OF STAINLESS STEEL Stainless steel is a marvelous material: strong, lustrous and low maintenance. With a minimum of care, it will normally retain its beauty and durability for the life of the equipment. In some applications, however, special care is required in order to maintain stainless steel’s special properties. External components, such as cabinets and control panels, are finished with a grain pattern.
CLEANING INSTRUCTIONS Shock Hazard DAILY CLEANING INSTRUCTIONS PREPARATIONS: Turn control knob(s) to OFF. Allow warmer to cool before proceeding. Remove any insets, pans and/or adapter tops ( if used). Drain or remove water from well if used for wet operation. FREQUENCY: Minimum - daily.
CLEANING INSTRUCTIONS WEEKLY CLEANING INSTRUCTIONS M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw. Warmers PREPARATIONS: CAUTION: Remove any insets, pans and/or adapter tops. Drain or remove water from well if used for wet operation. FREQUENCY: Weekly, or whenever lime or scale is seen accumulating on the sides of the warmer pans. TOOLS: Commercial Delime Cleaner Plastic Scouring Pad Clean Cloth or Sponge 1.
TROUBLESHOOTING SUGGESTIONS SYMPTOM POSSIBLE CAUSE No power to warmer Circuit breaker off or tripped Reset circuit breaker Warmer will not heat Temperature control not set Set control to desired temperature Wet insulation Verify flange-to counter seal is sound, or reseal with food-grade silicone sealant Pan leaking or other internal damage Contact your Authorized Wells Service Agency for repairs Internal damage Contact your Authorized Wells Service Agency for repairs Mineral deposits on pan ac
M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw.
EXPLODED VIEW: SS206, SS206D 1 2 5 3 9 4 6 7 12 11 8 13 16 14 15 Model: SS206, SS206D PL012B IL1861 Rev. A 8/10/09 12 M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw.
PARTS LIST: SS206, SS206D SS206, SS206D Fig No 1 Description P2-31869 SCREEN DRAIN ASSY WARMERS P2-30401 PAN W/O DRAIN P2-30402 PAN W/DRAIN WS-62059 BOX CONTROL SS8, SS10, SS206 2E-34594 SWITCH INFINITE 120V 2E-34593 SW INF 240V B CAM 13/16S 5 2C-43271 CLIP RETAINER PILOT LIGHT 6 2V-WL0049 PANEL, CONTROL OVAL/GUARD 7 2C-34284 RIVET POP 3/32DX1/8 8 2R-44373 KNOB CONTROL ASSY WARMERS 9 WS-50385 LIGHT SIGNAL RED PUSH ON WS-64486 ELEM ASSY 120V 1200W & PAN WS-64485 ELEM ASSY 240
EXPLODED VIEW: SS206E, SS206ED, SS206ER, SS206ERD 1 2 5 3 6 11 7 10 8 9 Model: SS206E, SS206ED, SS206ER, SS206ERD, PL012B IL1862 Rev. A 8/10/09 14 M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw.
PARTS LIST: SS206E, SS206ED, SS206ER, SS206ERD SS206E, SS206ED, SS206ER, SS206ERD Fig No 1 Description Application 5P-21709 SCREEN DRAIN WARMERS ALL P2-38722 PAN W/O DRAIN SS206E SS206E P2-34908 PAN WITH DRAIN SS206ED SS206ED P2-38522 PAN W/O DRAIN SS206ER SS206ER P2-38523 PAN W/DRAIN SS206ERD SS206ERD 2E-34594 SWITCH INFINITE 120V 120V 2E-34593 SW INF 240V B CAM 12/16S 240V 4 2R-44373 KNOB CONTROL ASSY WARMERS ALL 5 WS-50385 LIGHT SIGNAL RED PUSH ON ALL 6 2C-30467 CLAMP E
M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw.
M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw.
M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw.
M012B.01 2M-308028 Owners Manual for SS206 Built-In Inf Sw.
PARTS & SERVICE DESCRIPTION PART NO. ADAPTERS & INSETS Adapter top, convert SS206 to hold two 7 qt. insets WS-20176 Adapter top, convert SS206 to hold two 4 qt. insets and two 2½ qt. insets WS-20434 Adapter top, convert 12” x 20” warmer to hold two 7 qt. insets WS-21502 Adapter top, convert 12” x 20” warmer to hold two 4 qt. and two 2½ qt DD-21503 Adapter top, convert 12” x 20” warmer to hold three 4 qt. insets DD-21616 Adapter top, convert 12” x 20” warmer to hold one 7qt.
PARTS & SERVICE DESCRIPTION PART NO. ACCESSORIES 6 oz. SOUP LADLE 2L-47567 DRAIN VALVE EXTENSION KIT, extension from drain to counter front with remote handle, for use with “D” models only, excluding “DM” models 5P-20385 IMPORTANT: Use only factory authorized service parts and replacement filters. For factory authorized service, or to order factory authorized replacement parts, contact your Wells authorized service agency, or call: Wells Bloomfield, LLC 10 Sunnen Dr., P.O.Box 430129 St.
WELLS BLOOMFIELD, LLC 10 Sunnen Dr., St. Louis, MO 63143 telephone: 314-678-6314 fax: 314-781-2714 www.wellsbloomfield.
