595 WELLS BLOOMFIELD, LLC 10 Sunnen Dr., St. Louis, MO 63143 telephone: 314-678-6314 fax: 314-781-2714 www.wellsbloomfield.
LIMITED WARRANTY STATEMENT Unless otherwise specified, all commercial cooking equipment manufactured by WELLS BLOOMFIELD, LLC is warranted against defects in materials and workmanship for a period of one year from the date of original installation or 18 months from the date of shipment from our factory, whichever comes first, and is for the benefit of the original purchaser only.
TABLE OF CONTENTS WARRANTY SPECIFICATIONS FEATURES & OPERATING CONTROLS PRECAUTIONS & GENERAL INFORMATION AGENCY LISTING INFORMATION INSTALLATION OPERATION CLEANING INSTRUCTIONS TROUBLESHOOTING SUGGESTIONS EXPLODED VIEW & PARTS LIST WIRING DIAGRAM SERVICING INSTRUCTIONS PARTS & SERVICE xi 1 2 3 3 4 5 6 7 8 10 11 13 INTRODUCTION Thank You for purchasing this Wells Bloomfield appliance.
FEATURES & OPERATING CONTROLS M595 p/n 2M-75982 Owners Manual Heated Dispenser Fig.
PRECAUTIONS AND GENERAL INFORMATION WARNING: Electric Shock Hazard All servicing requiring access to non-insulated components must be performed by qualified service personnel. Do not open any access panels which require the use of tools. Failure to heed this warning can result in electrical shock. WARNING Electric Shock Hazard Warmer must be properly grounded to prevent possible shock hazard. Electrical shock will cause death or serious Injury. This appliance is intended for commercial use only.
INSTALLATION READ THIS CAREFULLY BEFORE STARTING THE INSTALLATION CAUTION: Equipment Electrical Damage DO NOT plug in or energize this appliance until all Installation Instructions are read and followed. Damage to the Brewer will occur if these instructions are not followed. CAUTION: Unstable Equipment Hazard REFER TO EXPLODED VIEWS PAGE 9 FOR COMPONENT NAMES/NUMBERS Unpack the unit. Inspect all components for completeness and condition. Ensure that all packing materials have been removed from the unit.
OPERATION PREPARATION Prior to first use, thoroughly clean warmer (see page 6). Be sure faucet handle is "up" and that drip tray is in place under faucet. CAUTION: Burn Hazard Exposed surfaces of the appliance may be HOT to the touch and can cause burns. USE Pour product into warming tank. Using pre-heated product will reduce heat-up time. Model HD8799 utilizes a fixed thermostat to hold product at 140ºF (60ºC). Model HD8802 thermostat may be adjusted to hold product at 170ºF (77ºC) maximum.
CLEANING INSTRUCTIONS CAUTION: Electric Shock Hazard Do not submerge or immerse dispenser in water. CAUTION: PROCEDURE: Clean Heated Dispenser PRECAUTIONS: Disconnect dispenser from electric power. Drain product and allow dispenser to cool. FREQUENCY: Daily or after draining product from dispenser TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Long Handle Bristle Brush Burn Hazard This procedure requires the use of very hot water. Wear protective gloves while cleaning the warmer.
TROUBLESHOOTING SUGGESTIONS SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDY Not plugged in or circuit breaker off or tripped Restore electric power to warmer Power switch not ON Turn power switch to ON Internal wiring damage Inspect wiring for burnt wires and proper connections .
EXPLODED VIEW & PARTS LIST MODEL HD8799 2½-GALLON DISPENSER 1 PART NO 2U-87737 DESCRIPTION QTY ITEM FAUCET ASSEMBLY 1 PART NO DESCRIPTION 6 2N-75853 HEATING ELEMENT 120V 200W QTY 1 1.1* WS-8600-15 FAUCET SPB PLASTIC (BLK) 7 2T-75863 THERMOSTAT 140ºF 120V 1 1.2* 2U-71460 SEAT CUP 8 2E-30169 SWITCH 250V DPST 1 ASSEMBLY, HANDLE & PLUNGER 9 Z1-70-07-0343 GUARD, SWITCH 1.4* WS-8600-27P NUT RETAINING WINGED 10 2E-70017 POWER CORD, 120V NEMA5-15P, 6' 1 1.
EXPLODED VIEW & PARTS LIST M595 p/n 2M-75982 Owners Manual Heated Dispenser MODEL HD8802 5-GALLON DISPENSER Model: HD8802 5 Gallon Dispenser ITEM 1 PART # 2U-87737 1.1* WS-8600-15 1.2* 2U-71460 1.
WIRING DIAGRAM M595 p/n 2M-75982 Owners Manual Heated Dispenser 10
SERVICING INSTRUCTIONS ACCESS - BOTTOM PANEL All internal components are accessible by removing the bottom panel. Remove four screws around the bottom of the warmer tank to free bottom panel from tank assembly. FAUCET The faucet may be removed from the shank by turning the winged collar clockwise. CAUTION Electric Shock Hazard Opening the bottom panel will expose uninsulated electrical components. Disconnect dispenser from electrical power before removing bottom panel.
NOTES M595 p/n 2M-75982 Owners Manual Heated Dispenser 12
PARTS & SERVICE DESCRIPTION PART NO. DRIP TRAY 2L-71747 IMPORTANT: Use only factory authorized service parts and replacement filters. For factory authorized service, or to order factory authorized replacement parts, contact your Wells authorized service agency, or call: Wells Bloomfield, LLC 10 Sunnen Dr., St. Louis MO 63143 USA Service Dept.
WELLS BLOOMFIELD, LLC 10 Sunnen Dr., St. Louis, MO 63143 telephone: 314-678-6314 fax: 314-781-2714 www.wellsbloomfield.
