351 WELLS BLOOMFIELD, LLC 2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439 telephone: 775-689-5703 fax: 775-689-5976 www.wellsbloomfield.com OPERATION MANUAL MODEL F-49RT COUNTERTOP PASTA RETHERMALIZER Includes INSTALLATION USE & CARE Model F-49RT IMPORTANT: DO NOT DISCARD THIS MANUAL This manual is considered to be part of the appliance and is to be given to the OWNER or MANAGER of the restaurant, or to the person responsible for TRAINING OPERATORS of this appliance.
LIMITED WARRANTY STATEMENT Unless otherwise specified, all commercial cooking equipment manufactured by WELLS BLOOMFIELD, LLC is warranted against defects in materials and workmanship for a period of one year from the date of original installation or 18 months from the date of shipment from our factory, whichever comes first, and is for the benefit of the original purchaser only.
TABLE OF CONTENTS WARRANTY SPECIFICATIONS FEATURES & OPERATING CONTROLS PRECAUTIONS & GENERAL INFORMATION AGENCY LISTING INFORMATION INSTALLATION OPERATION CLEANING INSTRUCTIONS MAINTENANCE TROUBLESHOOTING SUGGESTIONS PARTS & SERVICE CUSTOMER SERVICE DATA xi 1 2 3 4 4 6 7 8 8 9 9 INTRODUCTION Thank You for purchasing this Wells Bloomfield appliance.
FEATURES & OPERATING CONTROLS 2 351 p/n 304366 OpM Countertop Rethermalizer F-49RT Fig.
PRECAUTIONS AND GENERAL INFORMATION WARNING: BURN HAZARD Contact with boiling water can cause severe burns. Always wear protective clothing and heat resistant gloves when operating the appliance. WARNING: ELECTRIC SHOCK HAZARD All servicing requiring access to non-insulated components must be performed by qualified service personnel. DO NOT open any access panel that requires the use of tools. Failure to heed this warning may result in severe electric shock.
AGENCY LISTING INFORMATION This appliance conforms to NSF Standard 4 for sanitation only if installed in accordance with the supplied Installation Instructions and maintained according to the instructions in this manual. STD 4 This appliance is U Listed under UL File E6070 for 208V and 240V. E6070 INSTALLATION UNPACKING & INSPECTION Carefully remove the appliance from the carton.
INSTALLATION (continued) WARNING: ELECTRIC SHOCK HAZARD All servicing requiring access to non-insulated electrical components must be performed by a factory authorized technician. DO NOT open any access panel which requires the use of tools. Failure to follow this warning can result in severe electrical shock. F-49RT RETHERMALIZER ELECTRICAL INSTALLATION CAUTION: This unit is equipped with a cord and NEMA 6-30P plug, and requires a properly installed NEMA 6-30R receptacle.
OPERATION WARNING: BURN HAZARD Contact with boiling water can cause severe burns. Always wear protective clothing and heat resistant gloves when operating the appliance. CAUTION: NORMAL OPERATION HOT SURFACE 1. a. Be sure the TEMPERATURE CONTROL KNOB is turned to OFF. b. Lower the ELEMENT HEAD into the frypot by pushing back on the BASKET SUPPORT ROD, raising the ELEMENT HEAD SUPPORT ROD, then carefully lowering the elements. Exposed surfaces can be hot to the touch and may cause burns. 2.
CLEANING INSTRUCTIONS WARNING: BURN HAZARD Contact with hot water can cause severe burns. Allow the appliance to cool before cleaning. Always wear protective clothing and heat resistant gloves when cleaning the rethermalizer.
TROUBLESHOOTING SUGGESTIONS DESCRIPTION Unit will not heat POSSIBLE PROBLEM SUGGESTED REMEDY Not plugged in or circuit breaker tripped Plug into proper receptacle Reset circuit breaker Temperature control knob not set to desired temperature Set to desired temperature Hi-limit safety tripped Clean element1, reset hi-limit Damaged internal component Contact Wells Authorized Service Agency for repairs Temperature control thermostat thermobulb contaminated with cooking debris Clean element2 Damaged
WIRING DIAGRAM FOR F-49RT 208V OR 208/240V SINGLE PHASE HEATING ELEMENT HEAD ASSY DISCONNECT TILT SWITCH 13 215°F CONTROL THERMOSTAT 10 10 9 9 HEAT LIGHT (AMBER) TROUBLE LIGHT (RED) WATTS VOLTS AMPS PER PHASE 3.5/4.6 KW 208/240 16.6/19.1 4.6 KW 208 22.
PART # DESCRIPTION PART # OPTIONAL ACCESSORIES DESCRIPTION PART # MECHANICAL DESCRIPTION HARDWARE, etc.
F-49RT COUNTERTOP PASTA RETHERMALIZER 66648 50177 fiber washer 50176 lock washer (pk 10) 50516 amber 51157red 20141 66548 temp control 50172 69689 (pk 4) 50789 55736 66549 green KEP (pk 10) hi-limit safety 21365 (pk 4) 69689 (pk 4) 62892 (240V) 21747 54452 53436 53435 53890 52428 52427 T SE (pk 10) RE 51208 51207 51206 PL351 Service Parts List - F-49RT Countertop Pasta rethermalizer (pk 4) 50147 55566 (pk 100) 21748 20314 plastic 20563 metal (pk 4) 3
PARTS & SERVICE DESCRIPTION PART NO. LEGS, ADJUSTABLE (Set of 4) COVER, FRYPOT PORTION BASKET, PK OF 4 RACK, PORTION CUP POT, SS WITH HANDLES BASKET, SS 1/2 SIZE 20563 21010 21365 21747 21748 22070 IMPORTANT: Use only factory authorized service parts and replacement filters. For factory authorized service, or to order factory authorized replacement parts, contact your Wells authorized service agency, or call: Wells Bloomfield, LLC 2 Erik Circle P. O. Box 280 Verdi, NV 89439 Service Parts Dept.
Commercial Food Equipment Service Association Wells Bloomfield proudly supports CFESA Commercial Food Equipment Service Association SERVICE TRAINING - QUALITY SERVICE Genuine Parts Protect - YOU - All - Ways CUSTOMER SATISFACTION WELLS BLOOMFIELD, LLC 2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439 telephone: 775-689-5703 fax: 775-689-5976 www.wellsbloomfield.
