Instructions Sauna heater

9
Note:
The control equipment may be destroyed even if it is
incorrectly connected only once. The warranty will be
voided if the electrical connection is not correct.
Instructions for the electrician
DINVDE0100andAccidentPreventionRegulationBGVA2
mustbeobservedforconnectingthestoveandallelectrical
systems.Anexternalall-poledisconnectingdevicewithfull
isolationaccordingtoovervoltagecategoryIIImustbeinstalled.
Important:
Mains connection leads must be exible cables with
polychlorophenesheaths.Noconnectionleadsaresupplied
withthestove.Allthecablesinstalledinsidethecabinmust
besuitableforanambienttemperatureofatleast170°C.heat
resistantsiliconcablesmustbeused.Theminimumcross-
sectionoftheconnectioncableandtheminimumsizeofthe
saunacabinareshowninthetable(Table1page8).Makethe
electricalconnectionasshownintheconnectiondiagram.
Aconnectiondiagramisadditionallyaxedtotheinsideofthe
ductcover.Fitthecoveraftermakingtheelectricalconnection.
Pleasenotethatlivecablesmustnotberoutedvisiblyonthe
internalwallsofthecabinforsafetyreasons.Inprefabricated
saunacabins thewallelement with the air supplyopening
generallyhasemptycableconduitsoraductforroutingthecable.
Ifyourcabindoesnothaveanycableroutingpreparations,
we recommend that you install a connection socket (not
supplied)totheoutsideofthecabin.Drillaholeinthecabin
wallnearthecableinfeedfromthestoveandtheconnection
socket. Thread the cable through the hole to the external
connection socket. All cables must be protected from
damage. This can be achieved using installation ducting/
pipingorusingwoodencovers.
Connection diagram
Testing the insulation resistance
The resistance values between the various conductor
terminalsandthehousing(protectiveearth)canbemeasured
using an insulation resistance measuring unit. The total
insulation resistancebetween the conductor terminals and
housing(protectiveearth)mustdenitelybegreaterthan1
MOhm.Regulation3oftheDGUV(GermanSocialAccident
Insurance)Resistancevalueofindividualheatingcoils15-
44Ohm(3.6kw-9.0KW)
Position the sauna stones on the stone grid
Saunastonesareanaturalproduct.Werecommendthatyou
cleanthestoneswithcleanwaterbeforeplacingthemonthe
stove.Donotusestonesunlesstheyaredesignedforuse
inasauna. Use amaximumof10 kgofstones.Important.
Positionthestoneslooselyandremoveanystonesthatare
toosmall.Ifthestonesarepackedtootightlytheywillaect
theaircirculationandwillresultinthesaunastoveandcabin
wallsoverheatingandarerisk.Donotusethestovewithout
stones.Onlyusestonesthataremarkedassaunastonesin
shops.Warrantyclaimswillnotbeacceptedifstonesother
thanthosedesignedforuseinsaunasareusedorforclaims
resultingfromllingofthestonechambersincorrectly.Turn
thestonesatleastonceperyear,removeanystonesthatare
toosmallandremoveallstonedustandstonesplinters.We
recommendthatyoureplacethestoneseverytwoyears.
Important:
Ifyoucoverthestoveandllthestonecontainerincorrectly
theunitmaycauseare.Donotusethestovewithoutsauna
stones.
Cleaning and care:
Switchothestoveandallowittocoolbeforeyoucleanit.
Donotusescouringcleaningproductstocleanthestove.
9 kW sauna stove with internal controller
Weka_Anleitung_Saunaofen_IPX4.indd 9 13.07.17 10:03