Install Instructions

Installation and Gas Boiler Data Collection Sheet
Boiler Model / Series EVG ________ / Series _______ Date Installed: ___________________
CP Number: __________________ Fuel Type: Natural___ LP___ BTU Input: ____________
Flame signal on control display at HIGH fi re: _________________ Flame signal on control display at LOW fi re: ____________
Was venturi changed? YES___ NO___ Was gas valve throttle adjusted? YES___ NO___ Was gas valve offset adjusted? YES___ NO___
Boiler Settings Network Settings Priority 1 Settings
Boiler Model: EVG ______ Boiler Address: ____ System Type: ___________
Control Type: _________ Net Max On Time: _____Min Target Mod Sensor: ___________
Altitude: _________Feet Net Min On Time: _____Min Target Adjust: ___________
LP Gas: YES___ NO___ Max Rate On Net: _____% Supply Max: ___________˚F
ODT Sensor Exempt: YES___ NO___ Min Rate On Net: _____% Supply Min: ___________˚F
Manual Reset High Limit Temp: ____˚F Rotation & Sequence OD Reset Max: ___________˚F
WWSD Temp: ____˚F Sequence Type: ______ OD Reset Min: ___________˚F
Adjust Outdoor: ____˚F Base Rate High: _____% Volts For Max: ___________ V
Circulator Exercising Base Rate Low: _____% Volts For Min: ___________ V
Circulator 1: ON___ OFF___ Boiler Rotation Type: _________ Boost Time: ___________ Mins
Circulator 2: ON___ OFF___ Rotate Frequency: ____Days System Off Diff: ___________˚F
Circulator 3: ON___ OFF___ Force Lead Rotation: YES or NO System On Diff: ___________˚F
Boiler Circ: ON___ OFF___ Modbus Settings Add BLR Diff: ___________˚F
Freeze Protection Enable: YES___ NO___ Drop BLR Diff: ___________˚F
Circulator 1: ON___ OFF___ Address: __________ Mod Delay Time: ___________ Mins
Circulator 2: ON___ OFF___ Parity Bit: __________ Stabilization Time: ___________ Mins
Circulator 3: ON___ OFF___ Baud Rate: _________bps Add Delay Time: ___________Sec
Boiler Circ: ON___ OFF___ Stop Bit: YES___ NO___ Drop Delay Time: ___________Sec
Assign Inputs Max BLR Temp: ___________˚F
Input 1: Priority___ Aux___ OFF___ Boiler On Diff: ___________˚F
Source: TT1 ___ OR 0-10V ___ Boiler Off Diff: ___________˚F
Input 2: Priority___ Aux___ OFF___ Max On Time: ___________ Mins
Input 3: Priority___ Aux___ OFF___ Run Boiler Pump: YES___ NO___
Run Aux Pump/Output: YES___ NO___
Pre Pump: ___________Sec
Post Pump: ___________Sec
Max Rate: ___________%
Min Rate: ___________%
Max System BTUs: __________ MBUTs
Min Boilers On: ___________
Additional Heat Demand: 1st___ 2nd___ OFF__
Response Time: ___________ Mins
Part number 550-100-191/0917
142
®
gas-fired water boiler — 70/110/155 Boiler Manual