User Guide

GAS-FIRED WATER BOILERBoiler Manual
®
SERIES 4 GAS-FIRED WATER BOILERBoiler Manual
140
Installation and Service Certifi cate
34!2450$!4!
Boiler Model CO
2
High fi re % CO
2
Low fi re %
Fuel Natural ____ LP ____ CO High fi re ppm CO Low fi re ppm
Was orifi ce changed? ______________________________________ Was gas valve throttle adjusted (Ultra-399) for propane? __________________
Natural gas input rate measured _________________________ Btuh
5#/.42/,3%450$!4!
Boiler Model WWSD Temp °F Add’l Heat Demand Type 1___ 2___ 3___ 4___
High Altitude yes ____ no _____ Adjust Outdoor °F Add’l Heat Demand Time minutes
Manual Reset Temp °F
02)/2)493ETTINGS 02)/2)493ETTINGS 02)/2)493ETTINGS
System Type System Type System Type
Max Supply °F Max Supply °F Max Supply °F
Min Supply °F Min Supply °F Min Supply °F
Max OD Reset °F Max OD Reset °F Max OD Reset °F
Min OD Reset °F Min OD Reset °F Min OD Reset °F
Modulate On Diff °F Modulate On Diff °F Modulate On Diff °F
Modulate Off Diff °F Modulate Off Diff °F Modulate Off Diff °F
Max On Time minutes Max On Time minutes Max On Time
Min On Time Min On Time minutes Min On Time minutes
Boost Interval minutes Boost Interval minutes Boost Interval minutes
Pre-pump Time: seconds Pre-pump Time: seconds Pre-pump Time: seconds
Post-pump Time: seconds Post-pump Time: seconds Post-pump Time: seconds
Circulator 1 on-off Circulator 1 on-off Circulator 1 on-off
Circulator 2 on-off Circulator 2 on-off Circulator 2 on-off
Circulator 3 on-off Circulator 3 on-off Circulator 3 on-off
Maximum Rate %Rate Maximum Rate %Rate Maximum Rate %Rate
Minimum Rate %Rate Minimum Rate %Rate Minimum Rate %Rate
#IRCULATOR%XERCISING &REEZE0ROTECTION#IRCULATORS
Circulator 1 on _______ off _______ Circulator 1 on _______ off _______
Circulator 2 on _______ off _______ Circulator 2 on _______ off _______
Circulator 3 on _______ off _______ Circulator 3 on _______ off _______
Boiler Model Series CP Number Date Installed
BTU Input Installation instructions have been followed.
Check-out sequence has been performed.
Above information is certifi ed to be correct.
Information received and left with owner/maintenance person.
Installer
(Company) (Address) (Phone) (Installer's Signature)