User Guide

Part number 550-100-400/0717
128
Replacement parts
Replacement parts must be purchased through a local Weil-McLain distributor. When ordering,
specify boiler model and size and include description and part number of replacement part.
Results from using modifi ed or other manufactured parts will not be covered by warranty and
may damage boiler or impair operation.
Weil-McLain part numbers are found in Weil-McLain Boilers and Controls Repair Parts Lists.
4HEBOILERCONTAINSCERAMIClBERMATERIALS. Use care when handling these materials per
instructions on page 109 of this manual. Failure to comply could result in severe personal injury.
Reinstall boiler jacket front door after startup or servicing
Inspect boiler jacket front door gaskets and reinstall boiler jacket front door after start or
servicing. The boiler front door must be securely fastened to the boiler to prevent boiler from
drawing air from inside the boiler room. This is particularly important if the boiler is located
in the same room as other appliances. Failure to keep the door securely fastened could result in
severe personal injury or death.
&IGURE Propane conversion kits and instructions
The conversion kits listed below are only for use with Ultra Series 4 boilers. For series 1 or series 2 boilers,
refer to the boiler manual or contact Weil-McLain for the correct parts.
.ATURALTOPROPANECONVERSIONSERIES 4 BOILERS ONLY
(not required for Ultra-399 — adjustment is made with throttle screw, not with orifi ce)
3EALEVELTOFEETALTITUDE (IGHALTITUDEABOVEFEET
-ODEL +ITPART +ITLOCATION )NSTRUCTIONS -ODEL +ITPART +ITLOCATION )NSTRUCTIONS
Ultra-80
383-501-020
30%#)!,
/2$%2
In kit only
Ultra-80LP
383-500-644
30%#)!,
/2$%2
See page 48
or kit
Ultra-105
540-100-001
Supplied with boiler
See page 48
Ultra-105
383-500-645
30%#)!,
/2$%2
See page 48
or kit
Ultra-155
383-500-115
Supplied with boiler
See page 49
Ultra-155
383-500-646
30%#)!,
/2$%2
See page 49
or kit
Ultra-230
383-500-120
Supplied with boiler
See page 49
Ultra-230
383-500-647
30%#)!,
/2$%2
See page 49
or kit
Ultra-299
540-202-832
Supplied with boiler
See page 49
Ultra-299
383-500-394
30%#)!,
/2$%2
See page 49
or kit
Ultra-310
540-202-833
Supplied with boiler
See page 49
Ultra-310
383-500-648
30%#)!,
/2$%2
See page 49
or kit
0ROPANETONATURALCONVERSION

383-501-021
30%#)!,
/2$%2
In kit only
Contact factory
Boilers marked with this symbol require special installation procedures. Do not use the instructions in this manual — use only
the instructions supplied in the conversion kit.
®
SERIES 4 GAS-FIRED WATER BOILERBoiler Manual