Install Instructions

Part number 550-100-090/1113
GAS-FIRED WATER BOILER — Boiler Manual
116
&IGURE Heat exchanger and piping — Ultra-80 and -105
Item Description
Boiler
Models
Part Number
 (EATEXCHANGERREPLACEMENTKIT(EATEXCHANGERCOVERPLATEBURNER
ELECTRODEWATERSENSORSCOMPRESSIONlTTINGSCONDENSATElTTINGGASKETS
ANDHARDWARE
.'
,0




2 #OVERPLATEREPLACEMENTKIT#OVERPLATECOVERPLATEGASKETBURNERGASKET
ANDHARDWARE
 
 #OVERPLATEGASKETINSULATION  
4 "URNERGASKET  
5 #OVERPLATESTUDS-PITCH !LL 
 #OVERPLATENUTS-PITCH !LL 
 7ATERCOMPRESSIONlTTINGMM n 
8 7ATERCOMPRESSIONlTTINGMM  
 3UPPLYWATERPIPEASSEMBLY0IPETEMPERATUREWELLCHECKVALVECAP
ASSEMBLEDCOMPRESSIONlTTING
 
 3UPPLYWATERLOWERPIPECLAMPANDHARDWARE  
 v.04WELLFORTEMPERATUREGAUGE !LL 
 0RESSURETEMPERATUREGAUGECHECKVALVE !LL 
 2ETURNWATERPIPEASSEMBLY0IPEDRAINVALVECAPASSEMBLED
COMPRESSIONlTTING
 
 "OILERDRAINVALVEv.04 !LL 
 "LOWERASSEMBLYKIT"LOWERGASKETANDHARDWARE  
 'ASPIPE  
 &LEXIBLEGASLINESECTIONANDSHUTOFFVALVE  
 'AS0IPELOWERPIPECLAMPANDHARDWARE  
 'ASVALVEVENTURIKIT'ASVALVEVENTURIªELBOWGASKETSANDHARDWARE
ASSEMBLED&OR,0BOILERSMAKESURETOREINSTALLTHEEXISTINGPROPANEORIlCE




 'ASKETCORKFORINBETWEENGASVALVEVENTURIBURNERINLET !LL 
 !IRSILENCERKIT!IRSILENCERANDGASKET  
22 !IRSILENCERADAPTERKIT!IRSILENCERADAPTERANDHARDWARE  
 #ONDENSATETRAPKIT#ONDENSATETRAPHOSECLAMPSPVClTTINGSANDGASKET  
24 2ETURNSUPPLYSENSORKITSENSOR !LL 
25 )GNITIONELECTRODEKIT)GNITIONELECTRODESUPPRESSORGASKETANDHARDWARE !LL 
)GNITIONELECTRODEGASKET/.,9 !LL 
 )GNITIONCABLEKITNOTSHOWN)GNITIONCABLESUPPRESSORANDWIRETIE !LL 
 )NSPECTIONGLASSKIT"RACKETGLASSGASKETANDHARDWARE !LL 
28 "URNERREPLACEMENTKIT"URNERGASKETSANDHARDWARE .'
,0




 'ASKETRUBBERBLOWER  
 #ONDENSATElTTING  
Replacement parts (continued)