User Guide
8
Part Number 550-142-301/0420
CGa, CGi, EG, PEG, & LGB Gas-Fired Boilers
User maintenance procedures
Donotattempttoplaceboilerinoperationifspillswitch
cuts off gas flow. Immediately call a service technician.
Failure to do so can cause severe personal injury, death
or substantial property damage.
Rollout thermal fuse element
CGa, CGi, EG, & PEG only
Cutsoff gas flowshouldflamerollout occur.See
Figure 1.
Donotattempttoplaceboilerinoperationifrollout
thermal fuse element cuts off gas flow. Immediately call
a service technician. Failure to do so can cause severe
personal injury, death or substantial property damage.
Spill switch
CGa, EG, & PEG only
Cuts off gas flow should vent system become blocked.
SeeFigure 2.
Figure 1
Rollout thermal fuse element
Figure 2
Spill switch
Component information
Boiler area
To prevent potential of severe personal injury, death
or substantial property damage, eliminate all materials
discussed below from the boiler vicinity. If found:
• Removeproductsimmediatelyfromthearea. If
they have been there for an extended period, call a
qualified service technician to inspect the boiler and
vent system for possible damage from acid corrosion.
• Ifproductscannot be removed,immediatelycall
a qualified service technician to install an outside
combustion air source for the boiler (if not already
installed).
1. Combustible/flammablematerials—Donot
store combustible materials, gasoline or any
other flammable vapors or liquids near the boiler.
Remove immediately if found.
2. Aircontaminants—Seelistingofcontaminantson
page 3.
❏ Check daily . . . . . . . . . . . . . . . . .
The boiler should be inspected and started annually, at
the beginning of the heating season, only by a qualified
service technician. In addition, the maintenance and
care of the boiler designated on page 6 and explained
on the following pages must be performed to assure
maximum boiler efficiency and reliability. Failure to
service and maintain the boiler and system could result
in equipment failure, causing possible severe personal
injury, death or substantial property damage.
Boiler must be serviced & maintained
The following information provides
detailed instructions for completing
the maintenance items listed in
the maintenance schedule, page 6.
In addition to this maintenance,
the boiler must be serviced and
started up at the beginning of each
heating season by a qualified service
technician.