User Guide

GOLD CGt Gas-Fired Water Boiler User’s Information Manual
6
Part Number 550-110-291/0709
Air openings
Verify that combustion and ventilation air openings
to the boiler room and/or building are open and un-
obstructed.
Pressure/temperature gauge
1. Make sure the pressure reading on the boiler pres-
sure/temperature gauge does not exceed 24 psig.
Higher pressure may indicate a problem with the
expansion tank or gauge.
2. Contact a qualiedservice technicianifproblem
persists.
User maintenance procedures
Rollout thermal fuse element
Cutsoffgasowshouldamerolloutoccur.SeeFigure 1.
Do not attempt to place boiler in operation if rollout
thermalfuse element cuts off gasow. Immediately
call a service technician. Failure to do so can cause
severe personal injury, death or substantial property
damage.
Figure 1 Rollout thermal fuse element
Component information
Boiler area
To prevent potential of severe personal injury, death or
substantial property damage, eliminate all materials as
discussed below from the boiler vicinity. If found:
 • Removeproductsimmediatelyfromthearea.
If they have been there for an extended period, call
a qualified service technician to inspect the boiler
and vent system for possible damage from acid
corrosion.
 • Ifproducts cannotberemoved, immediately
call a qualified service technician to install an outside
combustion air source for the boiler (if not already
installed).
1. Combustible/flammable materials — Do not
store combustible materials, gasoline or any other
ammablevaporsorliquidsneartheboiler.Remove
immediately if found.
2. Aircontaminants—Seelistingofcontaminantson
page 3.
❏ Check daily . . . . . . . . . . . . . . . . . . .
The boiler should be inspected and started annually, at
the beginning of the heating season, only by a qualified
service technician. In addition, the maintenance and
care of the boiler designated on page 6 and explained
on the following pages must be performed to assure
maximum boiler efficiency and reliability. Failure to
service and maintain the boiler and system could result
in equipment failure, causing possible severe personal
injury, death or substantial property damage.
Boiler must be serviced & maintained
The following information provides
detailed instructions for completing
the maintenance items listed in
the maintenance schedule, page 6.
In addition to this maintenance,
the boiler must be serviced and
started up at the beginning of each
heating season by a qualified service
technician.