Product Manual
Table Of Contents
- 1 CALIFORNIA Proposition 65 Warning
- 2 Preface
- 3 Introduction
- 4 Security
- 4.1 Policy
- 4.2 Proper use
- 4.3 Structural changes
- 4.4 Areas of responsibility of the operator
- 4.5 Operator responsibilities
- 4.6 Personnel qualification
- 4.7 Residual dangers
- 4.8 General safety instructions
- 4.9 Specific safety instructions - Vibratory rammer AS
- 4.10 General safety instructions – fuel, lubricants and coolants
- 4.11 Maintenance
- 4.12 General safety instructions - Rechargeable battery (accessories)
- 4.13 General safety instructions - Battery charger (accessories)
- 4.14 Personal Protective Equipment
- 4.15 Behavior in dangerous situations
- 5 Safety and information labels
- 6 Setup and function
- 7 Components and operator's controls
- 8 Transport
- 9 Storage
- 10 Operation and use
- 11 Maintenance
- 12 Troubleshooting
- 13 Disposal
- 14 Disposal
- 15 Accessories
- 16 Technical data
- 17 Glossary
11 Maintenance
30 100_0201_mt_0002.fm
11 Maintenance
11.1 Maintenance table
WARNING
Improper handling may result in injury or serious material damage.
Please read and follow all safety instructions in this operator's manual.
WARNING
Risk of injury from uncontrolled starting of the machine and moving parts.
Only perform maintenance work with the machine switched off and battery dismantled.
WARNING
Warning of hot surfaces
The crankcase with the engine and guide cylinder can heat up greatly after even a short
period of time, which can lead to severe burns on contact with skin.
Always allow the engine to cool down completely after use.
If there is not enough time to allow the machine to cool down (e.g. in an emergency
situation.), use heat-resistant protective gloves.
WARNING
Electrical voltage
Risk of injury from electric shock.
Switch the machine off.
Remove the rechargeable battery.
Maintenance jobs Daily 50 hours 200 hours
Cleaning the machine
Inspect for completeness.
Visual inspection for damage.
Check the switching and safety lever for smooth and
effortless movement and function.
Grease the ramming system*
Check the oil level, top off if necessary.**
Change the oil**
1
Check the screwed connection.
Clean the rechargeable battery
Visual inspection for damage.
Clean the battery charger
Visual inspection for damage.
1
Perform first oil change after 50 hours.
*
AS30e
**
AS50e/AS60e