Specifications

– 9 –
4. Observe the water level gauge sight glass to verify the water level.
• Keep both valves on the water gauge open at all times.
5. Press the reset switch with green indicator light lit to light the boiler.
6. Both Low Water and High Pressure indicator lights must be off before the burner will ignite.
• If the indicator lights do not go off after 15 minutes or if they come on during normal operation,
press [ 0 ] for off and contact an authorized Vulcan-Hart servicer.
7. If the burner does not ignite after 30 seconds press [ 0 ] on the power switch for off, wait 5 minutes,
then repeat steps 1 – 5.
• If the ignition does not occur after 3 tries, press [ 0 ] on the power switch for off and contact an
authorized Vulcan-Hart servicer.
8. Steam generation will begin in about 10 minutes.
• Observe that the boiler pressure gauge indicates steam pressure in the range of 8 – 12 psig.
9. Set both timer dials to off.
10. Open both compartment doors and observe that no steam has entered the cooking compartments.
11. Close compartment doors.
12. Set both timer dials to 2 minutes.
• READY lights will go off.
• COOKING lights will come on.
• Steam will be heard entering the compartments.
13. Wait until 1 minute is left on the timers.
14. Open each door and observe that steam has stopped entering into each compartment.
• COOKING lights remain on.
15. Close compartment doors.
• Steam generation and timers resume.
• Make sure that steam from the drain is being cooled by water from the cold water condenser.
16. When timer dials are at 0 minutes, each buzzer will sound.
• Steam flow to the compartments will stop.
• COOKING lights will go off.
• READY lights will come on.
17. Turn timer dials to off position to silence buzzers.
18. Press [ 0 ] on the power switch on the boiler (Fig. 2) to turn the steamer off.
• Indicator lights are not lit.
• Boiler will automatically blow down.
AUTOMATIC BLOWDOWN
When [ 0 ] on the power switch on the boiler (Fig. 2) is pressed, the boiler will blow down for
approximately 5 minutes.