INSTALLATION & OPERATION MANUAL V SERIES FOOD HOLDING & TRANSPORTATION CABINETS AND BANQUET CARTS MODELS: VB90 VB96 VB150 VBP5I VBP7I VBP13I VBP15I VBP33 VBP77I VBS15 VHA9 VHA18 VHDP5 VHFA9 VHFA18 VHP3 VHP7 VHP8 VHP15 VHP20 ML-126548 ML-126550 ML-126552 ML-138030 ML-126358 ML-126359 ML-126360 ML-138075 ML-126361 ML-138033 ML-138072 ML-138073 ML-138035 ML-138070 ML-138071 ML-126343 ML-126344 ML-126345 ML-126346 ML-126347 For additional information on Vulcan-Hart or to locate an authorized parts and service
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL ELECTRICAL EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD STARTUP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE VICINITYOF THIS OR ANY OTHER APPLIANCE.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) TABLE OF CONTENTS IMPORTANT FOR YOUR SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 ELECTRICAL REQUIREMENTS . . . . . . . . . . . .
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) GENERAL If the cabinet is found to be damaged, save the packaging material and contact the carrier within 15 days of delivery. INTRODUCTION Vulcan-Hart Holding & Transport Cabinets and Banquet Carts are produced with quality workmanship and material. Proper installation, usage, and maintenance of your cabinet will result in many years of satisfactory performance.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS 5. Install tray slides in the cabinet. Make sure the hook on the end of the tray slide is up. (Fig. 1) F-41140 (06-11) ELECTRICAL REQUIREMENTS ELECTRICAL CODES & STANDARDS: The cabinet must accordance with: be installed in In the United States of America: 1. State and Local Codes. 2. National Electrical Code, ANSI/ NFPA-70 (latest edition.) Copies may be obtained from: The National Fire Protection Association, 1Batterymarch Park, Quincy, MA 02269.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) grounding type, contact an electrician. Do not remove the grounding prong from this plug. Verify that the power source matches the Serial Data Plate located on the lower back corner of the cabinet and the plug configuration before the connection is made. (Fig. 3) (Fig. 3) OPERATION Fan On/Off Switch: The Fan On/Off Switch turns the fan on only. The use of the fan is optional. Turn on fan if forced air holding is desired.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) It is recommended that prior to placing the cabinet in operation, that it be preheated at the highest temperature setting for a period of 30 to 45 minutes. 2. Switch the Fan switch to On if forced air holding is desired. The use of the fan is optional. Use of the fan keeps the temperature even throughout the cabinet. HOLDING OPERATING INSTRUCTIONS 3. Wait approximately 25 minutes for the cabinet to preheat. 4.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS If the protective film remains intact, the stainless steel will remain intact. However, if the film is damaged, the stainless steel can break down and rust. CLEANING electrical cleaning. Always power supply unplug before PREVENTIVE CARE: To prevent stainless steel breakdown, follow these steps: DAILY: 1. Unplug electrical power supply. 2. Allow warmer to cool before cleaning. 3. Clean the interior of the cabinet with a mild soap and water.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS If signs of breakdown appear, restore the stainless steel surface. First, thoroughly clean, rinse, and dry the surface. Then, on a daily basis, apply a high-quality stainless steel polish according to manufacturer’s instructions. F-41140 (06-11) HEAT TINT: Darkened areas, called “heat tint,” may appear on stainless steel exposed to excessive heat. Excessive heat causes the protective film to thicken.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) TROUBLESHOOTING SYMPTOMS POSSIBLE CAUSES Cabinet not connected to power source. Cabinet not operating Connect cabinet to power source. Check circuit breaker No power. GFCI or Ground Fault Circuit Indicator tripped REMEDY Check GFCI Moisture problem. Dry moisture problem. Shorted element Contact Authorized Service Provider. Pinched/damaged wire. Contact Authorized Service Provider. Damaged power cord.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) SPECIFICATIONS HEIGHT IN * (mm) WIDTH IN (mm) DEPTH IN (mm) SHIPPING WT. Lb. (kg) VOLTS WATTS AMPS VB90 71.75" (1822) 31.75" (806) 42.75" (1086) 242# (110 kg) 120 2000 16.6 VB96 62" (1575) 51.5" (1308) 29" (737) 435# (197 kg) 120 2000 16.6 VB150 73" (1854) 61.25" (1556) 29" (737) 590# (268 kg) 120 2000 16.6 VBP5I 33.25" (845) 26.5" (673) 33.75" (857) 173# (79 kg) 120 1000 8.3 VBP7I 39.75" (1010) 26.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) WIRING DIAGRAMS MODELS MANUFACTURED BEFORE 01/01/2010 VB90, VB96, VB150, VBP5I, VBP7I, VBP13I, VBP15I, VHP15, VHP20, VBS7, VBS15, VBP33 11
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS MODEL MANUFACTURED BEFORE 01/01/2010 VBP77I 12 F-41140 (06-11)
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS MODELS MANUFACTURED BEFORE 01/01/2010 VHP3, VHP7, VHP8 13 F-41140 (06-11)
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS MODELS MANUFACTURED AFTER 01/01/2010 VBP5I, VBP7I, VBP13I, VBP15I, VHP7, VHP15, VBS7, VBS15 14 F-41140 (06-11)
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS MODEL MANUFACTURED 01/01/2010 through 01/20/2011 VBP77I 15 F-41140 (06-11)
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS MODELS MANUFACTURED AFTER 5/16/11 VHFA9, VHFA18 MODELS MANUFACTURED THROUGH 5/15/11 VHFA9, VHFA18 16 F-41140 (06-11)
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (06-11) LIMITED ORIGINAL COMMERCIAL EQUIPMENT WARRANTY Vulcan (Vulcan) warrants its new product(s) to be free from defects in material and workmanship for a period of one (1) year from the date of original installation. Wolf Range is affiliated with Vulcan and thus Wolf products carry the same warranty as Vulcan products. This Warranty is subject to the following conditions and limitations: 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13.
V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS 18 F-41140 (06-11)
