Specifications

STORAGE AND PRESEASON PREPARATION
NOTE: Ensure air intake system does
not aspirate foreign objects which may
cause severe engine or damage.
7. Stop engine.
8. Reinstall the intercooler air outlet
hose, ensure it is properly aligned
as prior to removal to ensure proper
engine operation.
Exhaust System Protection
In areas where temperature may
freeze, water trapped in the exhaust
system and intercooler must be re-
moved.
Using the flushing connector located
on the port (LH) side of the stern, inject
pressurized air at 379 kPa (55 PSI) into
system until there is no more water
flowing from jet pump.
smo2009-002-132_c
1. Flushing connector
The followinghose can be fabricatedto
ease draining procedure.
smo2008-001-053_a
TYPICAL
1. Flushing connector adapter
2. Hose 12.7 mm (1/2 in)
3. Air hose male adapter
NOTICE
Failure to drain the ex-
haust system may cause severe
damage to the intercooler (sup
er-
charged models) and exhaust mani-
fold.
Remove special tools.
Engine Internal Lubrication
Open the seat.
Remove the air ventilation box over the
engine (as applicable).
Remove ignition coils, refer to
MAIN-
TENANCE PROCEDURES
.
Remove spark plugs, refer to
MAINTE-
NANCE PROCEDURES
.
Spray XPS Lube or equivalent, in spark
plug holes.
To prevent fuel from being injected and
to disable the ignition during engine
cranking, fully depress throttle lever
and HOLD against handlebar.
Press the start/stop button to crank the
engine a few turns. This will distribute
the oil on the cylinder walls.
Apply anti-seize lubricant on spark plug
threads, then reinstall them in the en-
gine. Refer to
MAINTENANCE PRO-
CEDURES
.
Install the ignition coils, refer to
MAIN-
TENANCE PROCEDURES
.
Engine Coolant Test
If antifreeze is not replaced, test its
density.
The antifreeze replacement and a den-
sity test should be performed by an au-
thorized Sea-Doo dealer.
NOTE: Antifreeze should be replaced
every 200 hours or every 2 years to
prevent antifreeze deterioration.
NOTICE
Improper antifreeze den-
sity may allow freezing of the liq-
uid in the cooling system if the wa-
tercraft is stored in an area where
the freezing point is attained. This
would seriously damage the engine.
Battery Removal and Charging
Contact your authorized Sea-Doo
dealer.
______________
129