SDS

ManualsBrandsVPI ManualsCleaning SuppliesESD Initial Deep Scrub Cleaner - 1 Gallon

Date of issue/Date of revision

: 4/13/2015.

Date of previous issue

: No previous validation.

Version : 1

1/12

SAFETY DATA SHEET

VPI ESD Initial Deep Scrub Cleaner

GHS product identifier

Other means of

identification

Product type

: VPI ESD Initial Deep Scrub Cleaner

: 04101G

: Liquid.

Relevant identified uses of the substance or mixture and uses advised against

Not applicable.

Supplier's details : VPI Corporation

3123 South 9th Street

P.O. Box 451

Sheboygan, WI 53082-0451

(920) 458-4664

! ! www.vpicorp.com

Emergency telephone

number (with hours of

operation)

: Chemtrec (800) 424-9300 24 hour

OSHA/HCS status : This material is considered hazardous by the OSHA Hazard Communication Standard

(29 CFR 1910.1200).

Classification of the

substance or mixture

: SKIN CORROSION/IRRITATION - Category 1

SERIOUS EYE DAMAGE/ EYE IRRITATION - Category 1

GHS label elements

Hazard pictograms :

Signal word : Danger

Hazard statements : Causes severe skin burns and eye damage.

Precautionary statements

Prevention

: Wear protective gloves: > 8 hours (breakthrough time): butyl rubber. Wear eye or face

protection: Recommended: splash goggles. Wear protective clothing. Wash hands

thoroughly after handling.

Response

: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for

breathing. Immediately call a POISON CENTER or physician. IF SWALLOWED:

Immediately call a POISON CENTER or physician. Rinse mouth. Do NOT induce

vomiting. IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse

skin with water or shower. Wash contaminated clothing before reuse. Immediately call

a POISON CENTER or physician. IF IN EYES: Rinse cautiously with water for several

minutes. Remove contact lenses, if present and easy to do. Continue rinsing.

Immediately call a POISON CENTER or physician.

Storage

: Store locked up.

Disposal

: Dispose of contents and container in accordance with all local, regional, national and

international regulations.

Section 1. Identification

Section 2. Hazards identification

Summary of content (12 pages)

PAGE 1
SAFETY DATA SHEET VPI ESD Initial Deep Scrub Cleaner Section 1. Identification GHS product identifier : VPI ESD Initial Deep Scrub Cleaner Other means of identification Product type : 04101G : Liquid. Relevant identified uses of the substance or mixture and uses advised against Not applicable. Supplier's details : VPI Corporation 3123 South 9th Street P.O. Box 451 Sheboygan, WI 53082-0451 (920) 458-4664 www.vpicorp.
PAGE 2
VPI ESD Initial Deep Scrub Cleaner Section 2. Hazards identification Hazards not otherwise classified : None known. Section 3. Composition/information on ingredients Substance/mixture : Mixture Other means of identification : Not available. CAS number/other identifiers CAS number : Not applicable. Product code : Ingredient name % CAS number Benzyl alcohol sodium xylenesulphonate 2-aminoethanol Alcohols, C9-11, ethoxylated ≥10 - <14 ≥3 - <5 ≥3 - <5 ≥1 - <2.
PAGE 3
VPI ESD Initial Deep Scrub Cleaner Section 4. First aid measures Most important symptoms/effects, acute and delayed Potential acute health effects Eye contact : Causes serious eye damage. Inhalation : No known significant effects or critical hazards. Skin contact : Causes severe burns. Ingestion : No known significant effects or critical hazards. Over-exposure signs/symptoms Eye contact Inhalation : Adverse symptoms may include the following: pain watering redness : No specific data.
PAGE 4
VPI ESD Initial Deep Scrub Cleaner Section 5. Fire-fighting measures Special protective equipment for fire-fighters : Fire-fighters should wear appropriate protective equipment and self-contained breathing apparatus (SCBA) with a full face-piece operated in positive pressure mode. Section 6. Accidental release measures Personal precautions, protective equipment and emergency procedures : No action shall be taken involving any personal risk or without suitable training. Evacuate surrounding areas.
PAGE 5
VPI ESD Initial Deep Scrub Cleaner Section 8. Exposure controls/personal protection Control parameters Occupational exposure limits Ingredient name Exposure limits Benzyl alcohol AIHA WEEL (United States, 10/2011). TWA: 10 ppm 8 hours. ACGIH TLV (United States, 4/2014). TWA: 3 ppm 8 hours. TWA: 7.5 mg/m³ 8 hours. STEL: 6 ppm 15 minutes. STEL: 15 mg/m³ 15 minutes. OSHA PEL 1989 (United States, 3/1989). TWA: 3 ppm 8 hours. TWA: 8 mg/m³ 8 hours. STEL: 6 ppm 15 minutes. STEL: 15 mg/m³ 15 minutes.
PAGE 6
VPI ESD Initial Deep Scrub Cleaner Section 8. Exposure controls/personal protection Body protection Other skin protection Respiratory protection Personal protective equipment (Pictograms) : Personal protective equipment for the body should be selected based on the task being performed and the risks involved and should be approved by a specialist before handling this product.
PAGE 7
VPI ESD Initial Deep Scrub Cleaner Section 10. Stability and reactivity Conditions to avoid : No specific data. Incompatible materials : No specific data. Hazardous decomposition products : Under normal conditions of storage and use, hazardous decomposition products should not be produced. Section 11.
PAGE 8
VPI ESD Initial Deep Scrub Cleaner Section 11. Toxicological information Information on the likely routes of exposure : Routes of entry anticipated: Oral, Dermal, Inhalation. Potential acute health effects Eye contact : Causes serious eye damage. Inhalation : No known significant effects or critical hazards. Skin contact : Causes severe burns. Ingestion : No known significant effects or critical hazards.
PAGE 9
VPI ESD Initial Deep Scrub Cleaner Section 12. Ecological information Toxicity Product/ingredient name Result Species Exposure Benzyl alcohol 2-aminoethanol Acute LC50 10000 µg/l Fresh water Acute EC50 8.
PAGE 10
VPI ESD Initial Deep Scrub Cleaner Section 14. Transport information DOT Classification TDG Classification Mexico Classification ADR/RID IMDG IATA UN number Not regulated. Not regulated. Not regulated. Not regulated. Not regulated. Not regulated. UN proper shipping name - - - - - - Transport hazard class(es) - - - - - Packing group - - - - - - Environmental hazards No. No. No. No. No. No.
PAGE 11
VPI ESD Initial Deep Scrub Cleaner Section 15. Regulatory information Name % Fire Sudden hazard release of pressure Reactive Immediate (acute) health hazard Delayed (chronic) health hazard Benzyl alcohol sodium xylenesulphonate 2-aminoethanol Alcohols, C9-11, ethoxylated ≥10 - <14 ≥3 - <5 ≥3 - <5 ≥1 - <2.8 No. No. Yes. No. No. No. No. No. Yes. Yes. Yes. Yes. No. No. No. No. No. No. No. No.
PAGE 12
VPI ESD Initial Deep Scrub Cleaner Section 16. Other information Caution: HMIS® ratings are based on a 0-4 rating scale, with 0 representing minimal hazards or risks, and 4 representing significant hazards or risks Although HMIS® ratings are not required on SDSs under 29 CFR 1910. 1200, the preparer may choose to provide them. HMIS® ratings are to be used with a fully implemented HMIS® program. HMIS® is a registered mark of the National Paint & Coatings Association (NPCA).