Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden XC90 © VolvoCar Corporation, 2007 Printed in Sweden Section Group Weight(Kg/Pounds) Year 3 393 4/8.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Required tools A0000162 IMG-239667 IMG-239664 IMG-239980 IMG-242205 R8802817 R3905015 © VolvoCar Corporation, 2007 Printed in Sweden 31260737 Page 2 of 20
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden R3903812 IMG-213320 © VolvoCar Corporation, 2007 Printed in Sweden 31260737 Page 3 of 20
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden INTRODUCTION ● ● NOTE! Read through the entire text before carrying out any work. The front page gives the date of this edition and the edition it replaces Cars equipped with SRS/SIPS (Airbag) Warning! Extra care must be taken when working on cars equipped with SRS/SIPS air bags. This is important to prevent: 1.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden in the centre console, in front of the parking brake. WARNING! The air bag inflation areas must not be obstructed. Never place any objects, such as upholstery or accessories, within these areas. The panels must be able to deploy in the correct manner at the right time otherwise there is a risk of personal injury in the event of a collision.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Preparations 1 Download the software for the accessory's function following the service information in VIDA. ● Note! The software must be loaded before installing the accessory. IMG-242268 Preparations 2 ● Place the driver's seat in its rearmost position. ● Turn the ignition switch to position 0.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden ● 3C Place the loudspeaker grille to one side. Illustration C ● Applies to cars without centre loudspeakers Remove the bracket for the loudspeaker grille by removing the five screws and pulling the grille up from the dashboard. Illustration D R3904127 ● Applies to cars with a centrally mounted loudspeaker Remove the five screws in the loudspeaker.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Preparations 6 ● Remove the center console's left-hand side panel by first pulling it away starting at the front edge and then backwards until all the clips have released. R8504165 Preparations 7A ● Image A. Applies to cars with Volvo on call (VOC) Remove the 4 VOC GPS tuner screws, the tuner will not be reused. ● Image B.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Preparations 9 ● Take the four rivet nuts from the kit and install them in the pre-punched holes under the carpet tabs. ● Take rivet tool P/N 9512782 and tighten the rivet nuts. If necessary: Remove the mounting bracket for front-rear seat adjustment (applies to cars with manual seats).
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Installing the antenna cable 13 ● Pull of the weatherstrip (1) for the door at the A-pillar. ● Remove the right-hand A-post panel by carefully pulling it out by the upper edge until the clips inside release. Pull it up from the mounting in the dashboard. Note! Do not damage the headlining.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Installing the antenna cable 17 D3902236 ● Wrap foam tape around the entire cable before installing. ● Install the new antenna. Carefully bend the headlining downward and slide the antenna backward and inwards. Align the antenna lugs (1) with the grooves in the bracket (2) ● Insert the cable on the top of the roof panel's front edge.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Installing the antenna cable 20 IMG-250470 ● Wrap foam tape around the entire cable before installing ● Take the extension cable from the kit. Insert it down between the A-post and the right-hand side of the dashboard, continue along the right-hand end of the dashboard and pull out at the front edge of the floor.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Does not apply to cars with (VOC) ● Route the antenna cable (4) in the same direction as cable harness (1) to Multimedia Module (MMM). Installing cable harness and antenna cable 23 ● Reinstall the A post panel. ● Tighten the grab handle to 10 Nm (7.5 lbf. ft.) and reinstall the covers. ● Reinstall the rubber trim in the right-hand front door. ● Reinstall the panel on the dashboard end face.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Installing and connecting the display screen. 27 ● Applies to all models Connect the gray connector from the power supply cable harness to the existing connector. ● Secure the excess gray connector. IMG-241303 Installing and connecting the display screen. 28 ● Connect the TMC cable (Europe) as illustrated.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Installing and connecting the display screen. 31 ● Take the bend protection from the kit and attach it with tape as illustrated. The bend protection is to prevent the fiber optic cable from bending too much, being damaged and risking malfunction of the accessory.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Connecting and installing the Multimedia Module (MMM) 34 ● Take four screws from the kit, place the Multimedia Module (MMM) mounting brackets above the rivet nuts and tighten the unit. ● Conceal the cables under the carpet at the rear of the Multimedia Module (MMM). ● Bend the carpet tabs back over the screws. Note! R3903837 Do not damage the fiber optic cables.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Installing the keypad in the steering wheel 37 ● Insert a screwdriver in the hole along the rear edge of the steering wheel perpendicular to the rear surface of the steering wheel. ● Insert the screwdriver as far as possible to find the end of the locking spring (1). ● Place the end of the screwdriver on the top of the locking spring.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Installing the keypad in the steering wheel 40 ● Turn the steering wheel to the left so that the right-hand side of the steering wheel points to the left. ● Take the cutting template from the kit and secure it to the right-hand side of the steering wheel as illustrated. ● Attach the template using a tie strap.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden Installing the keypad in the steering wheel 44 ● Install the screws and attach the keypad with the clamp around the steering wheel spoke. M3903757 Installing the keypad in the steering wheel 45 ● Position the horn ring and position it as illustrated. ● Plug in the installed keypad connector to the terminal on the back side of the keypad on the right-hand side of the horn ring.
Installation instructions, accessories - Navigation system, RTI Volvo Car Corporation Göteborg, Sweden clicks should be heard. ● Reinstall the surround for the combined instrument panel and the steering wheel cover. Installing the keypad in the steering wheel 48 ● Turn the ignition key to position II. ● Connect the battery negative lead.
