Safety data sheet

Conrad Electronic SE, Klaus-Conrad-Str. 1, D-92240 Hirschau
Item no. 101137
Material Safety Data Sheet
Page 6 of 7
The air transport of the lithium battery:
If all of following 7 requirements is satisfied, lithium metal cell/battery can be transported as no dangerous goods.
1. The lithium content of the lithium metal cell is 1g or less (battery: 2g or less).
2. Each cell/battery must meet requirements of the UN recommendation (Manual of Tests and Criteria, Part III, sub-section
38.3).
3. Package pass drop test (all courses) of 1.2m unless cell/butteries contained in equipment.
4. Each package must be labeled with a lithium battery handling label. (Each package containing more than four cells or two
batteries installed in equipment must be labeled with a lithium battery handling label.)
5. Each consignment must mention the following contents in an air waybill.
( i )The package contains Lithium metal cell/battery, and is no dangerous goods.
( ii ) The package must be handled with care and that a flammability hazard exists if the package is damaged.
( iii )Special procedures should be followed in the event the package is damaged, to include inspection and repacking if
necessary; and telephone number for additional information.
6. Satisfying government escape clause, an operator escape clause. It is necessary confirmation and correspondence so that
there is a setting case in a special provision by the government or an airline.
7. lf a person transports cell/battery, there be weight of the package within 2.5kg. About the detailed information, please
confirm the latest IATA-DRG (Packing Inspection 968,968,970)
Others instructions
Transportation regulation in USA:
Transport of primary lithium battery by passenger aircraft is forbidden in U.S.A. Transportation means other than a passenger
aircraft (Cargo aircraft, land transportation, marine transportation)is possible. However, the following message must be
indicated on the side of outer pack.
[PRIMARY LITHIUM BATTERIES — FORBIDDEN FOR TRANSPORT ABOARD PASSENGER AIRCRAFT] or [LITHIUM
METAL BATTERIES — FORBIDDEN FOR TRANSPORT ABOARD PASSENGER AIRCRAFT]
• High-contrast character colors (example: black characters on yellow base) should be used.
• The height of a character is regulated depending on package mass.
Total mass more than 30 kg : Minimum 12 mm
Total mass of 30 kg or less : Minimum 6 mm
About the detailed information, please confirm the latest USDOT-49CFR.
Storage/ Handling
Avoid high temperature, high humidity and condensation. Store batteries at room temperature (45°C or less: recommendation
is 20+/-15°C) with minimum temperature variations and a RH of not more than 70%. Carefully handle containers, and do not
strike them so strongly as denting a cell. Packing cells and prevent them from short-circuit. Also fix cells so as not to result in a
load shift during transportation.