Owner Manual

!
DANGER
If you smell gas:
• Shut off gas to the appliance.
• Extinguish any open flame.
• Open lid.
• If odor continues, keep away from the appliance and
immediately call your fire department.
!
WARNING
• Do not store or use gasoline or other flammable liquids
or vapors in the vicinity of this or any other appliance.
• Any LP cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
This instruction manual contains important information necessary for the proper assembly and safe use of
the appliance. Read and follow all warnings and instructions before assembling and using the appliance. Keep
this manual for future reference.
Always wait for grill to be completely cooled before opening built-in ash drawer.
When charcoal cooking above 500º F/260º C, with both top and bottom vents closed, rapidly opening the
lid creates a sudden rush of oxygen into the grill, which can cause a flare-up of flames. When in this cooking
mode, we recommend that, prior to opening the lid, you open both top and bottom vents to allow oxygen to
stabilize inside the grill before opening, minimizing the possibility of flare-ups.
GENERAL INSTRUCTIONS
1) The installation conforms with the National Fuel Gas Code, ANSI Z223.1/NFPA
54, Natural Gas and Propane Installation Code, CSA B149.1; or Propane Storage
and Handling Code, B149.2.
2) This outdoor cooking gas appliance shall be used only outdoors and shall not be
used in a building, garage or any other enclosed area.
3) This outdoor cooking gas appliance is not intended to be installed in or on boats
and not intended to be installed in or on recreational vehicles.
4) Minimum clearance from sides and back of unit to combustible construction,
32” from sides and 32” from back. The outdoor cooking gas appliance shall not
be used under overhead combustible surfaces.
5) Please inspect the hose before each use of the outdoor cooking gas appliance.
If it is evident there is excessive abrasion or wear, or the hose is cut, it must be
replaced prior to the outdoor cooking gas appliance being put into operation.
The replacement hose assembly shall be that specified by the manufacturer.
6) Lighting Instructions
(a) Read the instructions before lighting.
(b) Open lid during lighting.
(c) Confirm that the control knob on the gas insert is on the “OFF” position.
(d) Open the gas tank valve knob.
(e) Press and hold in the Red ignitor button. Device will emit a clicking sound.
(f) While holding in the Red ignitor button, Push in the control knob and turn to
“Low” position; a “click” will be heard, if operated correctly. Observe fire is lit.
(g) If ignition does not occur within 5 seconds, turn the burner control(s) off, wait
5 minutes, and repeat the lighting procedure.
7) Note
(a) Keep outdoor cooking gas appliance area clear and free from combustible
materials, gasoline and other flammable vapors and liquids.
(b) Do not obstruct the flow of combustion and ventilation air.
(c) Keep the ventilation opening(s) of the cylinder enclosure free and clear from
debris.
(d) Visually check burner flames including pilot burner flame.
(e) Clean outdoor cooking gas appliance, including special surfaces, with
recommended cleaning agents, if necessary.
(f) Check and clean burner/venturi tubes for insects and insect nests. A clogged
tube can lead to a fire beneath the grill.
8) If parts are missing, contact Vision Grills at [phone] or contact Vision
Grills via e-mail at [e-mail] or through the website at www.
visiongrills.com.
9) The cylinder diameter is 12”, the total height is 18” and volume is 20 lbs.
10) The LP gas supply cylinder(s) to be used must be constructed and marked:
(a) In accordance with the Specifications for LP-Gas Cylinders of the U.S.
Department of Transportation (D.O.T.) or the National Standard of Canada,
CAN/CSA-B339, Cylinders, Spheres and Tubes for Transportation of
Dangerous Goods; and Commission, as applicable.
(b) Provided with a listed overfilling prevention device.
(c) Provided with a cylinder connection device compatible with the connection
for outdoor cooking appliance.
11) If the outdoor cooking gas appliance is not in use, the gas must be turned off
at the supply cylinder. Storage of an outdoor cooking gas appliance indoors is
permissible only if the cylinder is disconnected and removed from the outdoor
cooking gas appliance.
Cylinders must be stored outdoors out of the reach of children and must not be
stored in a building, garage or any other enclosed area.
12) The pressure regulator and hose assembly supplied with the outdoor cooking
gas appliance must be used. If pressure regulator and hose assembly are
missing or need to be replaced, contact Vision Grills at [phone] or
contact Vision Grills via e-mail at [e-mail] or through the website
at www.visiongrills.com.
13) The cylinder used must include a collar to protect the cylinder valve.
14) (a) Do not store a spare LP-Gas cylinder under or near this appliance;
(b) Never fill the cylinder beyond 80 percent full; and
(c) If the information in “14-(a)” and “14-(b)” is not followed exactly, a fire
causing death or serious injury may occur.
15) Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only
install the type of dust cap on the cylinder valve outlet that is provided with the
cylinder valve. Other types of caps or plugs may result in leakage of propane.
16) Instructions, including illustrations, on the proper cylinder orientation to provide
vapor withdrawal.
Subject to the following terms and conditions, Phase 2, LLC, d/b/a Vision Grills (“Vision Grills”)
warrants to the original purchaser that the grill insert manufactured or supplied by Vision Grills
will be free from defects in material and workmanship under normal use for the following periods
from the original date of purchase: Five years for burner and all other metal parts; 90 days for lava
stone & bracket, quick disconnect, hose and regulator. This Warranty is contingent upon purchaser
registering the product at www.visiongrills.com/register or within 30 days from the date of purchase
along with a copy of the original dated sales receipt which can be attached in an electronic format
(i.e. scan, photograph, etc.) to your registration at www.visiongrills.com/register. Failure to do so will
invalidate the warranty. Any damages or defects present at the time of purchase must be noted on
the original dated sales receipt. This Warranty is not transferable to subsequent owners. If you cannot
register online, it will be necessary to contact Vision Grills customer service at [phone] or
email [e-mail].
If any product covered by this Warranty is defective due to a covered warranty condition, such product
will, at the option of Vision Grills, be repaired to its original condition or replaced with a comparable
new product or part. The repair and/or replacement of parts shall constitute the extent of the liability
and obligations of Vision Grills under this Warranty. Purchaser is required to provide photographic
evidence to assess the damage when submitting claim.
This Warranty does not cover damages caused by improper assembly, improper care, failure to follow
directions of use, misuse, abuse, negligence, extreme environmental conditions, normal wear and
tear, accidents, acts of nature, or unauthorized repair, alteration or modification, as determined by
Vision Grills. Vision Grills is not liable for any default or delay in its performance under this Warranty
that is caused by any circumstances beyond its control. While Vision Grills uses rust-resistant
materials, the Warranty as to metal parts does not cover rust or oxidation unless the structural
integrity of the grill insert is compromised as determined by Vision Grills.
This Warranty does not cover purchases with unauthorized resellers and/or third parties. Warranty
coverage is limited to products purchased at an authorized reseller only.
Commercial use and related applications are not covered under this Warranty. Warranty coverage is
based on normal residential use and maintenance.
Vision Grills shall not be liable for any delay or default under this Warranty caused by any event or
contingency beyond Vision Grills’s control. This includes acts of nature, fire, government restrictions
or restraints, strikes, reduced supply of materials or transportation delays.
THIS WARRANTY IS THE EXCLUSIVE WARRANTY OF VISION GRILLS. VISION GRILLS EXPRESSLY
DISCLAIMS ANY AND ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES
OF FITNESS, MERCHANTABILITY, OR FITNESS FOR A PARTICULAR PURPOSE. THIS WARRANTY
DOES NOT COVER, AND VISION GRILLS IS NOT LIABLE FOR, ANY DAMAGES RELATING TO LOSS
OF TIME, LOSS OF USE OF EQUIPMENT, INCONVENIENCE, OR ANY INCIDENTAL, SPECIAL AND/OR
CONSEQUENTIAL DAMAGES. PURCHASER’S EXCLUSIVE REMEDY FOR BREACH OF THIS WARRANTY
SHALL BE LIMITED AS SPECIFIED HEREIN TO REPLACEMENT OR REPAIR OF THE AFFECTED
PRODUCT.
Some states do not allow limitations on how long an implied
warranty lasts or the exclusion or limitation of incidental or
consequential damages, so the above limitations and exclusions
may not apply to you. This Warranty gives you specific legal rights,
and you may also have other rights which vary from state to state.
Vision Grills does not authorize any person or entity to assume
any obligation or liability on its behalf in connection with the sale
and purchase of any of its products. The purchase of any Vision
Grills product from anyone other than Vision Grills or an authorized
dealer will void the Warranty associated with the product. If you
have a question regarding the identity of an authorized dealer, you
should contact Vision Grills before you purchase the product.
To submit a warranty claim, the original purchaser or authorized
agent of the original purchaser must contact Vision Grills at (877)
917-4273 or contact Vision Grills via e-mail at help@visiongrills.
com or through the website at www.visiongrills.com.
WARRANTY
www.visiongrills.com [e-mail]
1-877-917-4273
Vision Grills 1531 Fairview Avenue, Suite B, St. Louis, MO 63132
WARNING: FUELS USED IN LIQUEFIED PROPANE GAS
APPLIANCES, AND THE PRODUCTS OF COMBUSTION OF SUCH
FUELS, CAN EXPOSE YOU TO CHEMICALS INCLUDING BENZENE,
WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
For more information go to: www.P65Warnings.ca.gov.
ADVERTENCIA: LOS COMBUSTIBLES USADOS EN EQUIPOS
PARA LICUAR GAS PROPANO, ASÍ COMO LOS PRODUCTOS DE SU
COMBUSTIÓN, PUEDEN EXPONERTE A SUSTANCIAS QUÍMICAS,
ENTRE ELLAS EL BENCENO, QUE EL ESTADO DE CALIFORNIA
RECONOCE COMO CAUSA DE CÁNCER Y DE MALFORMACIONES
CONGÉNITAS Y OTROS DAÑOS AL SISTEMA REPRODUCTOR.
Para más información, visite www.P65Warnings.ca.gov
WARNING: FUELS USED IN WOOD OR CHARCOAL BURNING
APPLIANCES, AND THE PRODUCTS OF COMBUSTION OF SUCH FUELS,
CAN EXPOSE YOU TO CHEMICALS INCLUDING CARBON BLACK, WHICH
IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND
CARBON MONOXIDE, WHICH IS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
For more information go to: www.P65Warnings.ca.gov.
ADVERTENCIA: LOS COMBUSTIBLES USADOS EN EQUIPOS PARA
QUEMAR MADERA O CARBÓN, ASÍ COMO LOS PRODUCTOS DE
TAL COMBUSTIÓN, PUEDEN EXPONERTE A SUSTANCIAS
QUÍMICAS, ENTRE ELLAS EL NEGRO DE HUMO Y EL MONÓXIDO
DE CARBONO, QUE EL ESTADO DE CALIFORNIA RECONOCE COMO
CAUSA, RESPECTIVAMENTE, DE CÁNCER Y DE MALFORMACIONES
CONGÉNITAS Y OTROS DAÑOS AL SISTEMA REPRODUCTOR.
Para más información, visite www.P65Warnings.ca.gov