Service manual

PARTS LIST
8-31
April 2001
Part No. 001-9800-203
RT 301 10k ohm thermistor 569-3013-007
U 100 Low volt sensor MC33164D 544-2003-074
U 101 Microcomputer, MC68HC11 544-5001-018
U 102 4k x 8 bit serial EEPROM X25320 544-5001-416
U 103 OR, 2-input quad 74HC32 544-3766-032
U 104 NAND, 2-input quad 74HC00 544-3766-000
U 105 Regulator, 5V .5A 78M05 544-2003-079
U 106 Demux, 10 of 8 74HC138 544-3766-138
U 107 8k x 8 CMOS static RAM AT3864 544-5002-115
U 108 EPROM, Flash 128k x 8
AT29C010
544-5001-211
U 109 Mux, 2-input quad 74HC157 544-3766-157
U 110 D-flip flop octal 74HC574 544-3766-574
U 111 D-flip flop octal 74HC574 544-3766-574
U 112 D-flip flop octal 74HC574 544-3766-574
U 113 2-input NAND, quad 74HC00 544-3766-000
U 300 Op amp, quad MC3303 544-2020-008
U 301 Op amp, quad MC3303 544-2020-008
U 302 Op amp, quad MC3303 544-2020-008
U 303 Op amp, quad MC3303 544-2020-008
U 304 Op amp, dual 2904 544-2019-004
U 305 Shift reg. 8-stage MC4094 544-3016-094
U 306 Audio amp, 3W w/vol control 544-2006-025
U 307 Bilateral switch, quad MC4066 544-3016-066
U 308 Bilateral switch, quad MC4066 544-3016-066
U 309 Shift register, 8-stage 4094 544-3016-094
Y 100 9.8304 MHz crystal 521-0009-830
Ref No Description Part No.
9800-SERIES RADIO MOUNTING KIT
PART NO. 023-9800-030
HW 001 Screw, No. 10 self drilling (4) 575-9077-545
MP 001 Tri knob (2) 547-0016-008
9800-SERIES REMOTE MOUNTING KIT
PART NO. 023-9800-040
HW 001 Screw, No. 10 self drilling (4) 575-9077-545
HW 002 Flat washer, vulcanized (2) 596-6400-030
MP 004 Mounting bracket, rem ctrl unit 017-2227-057
MP 001 Tri knob (2) 547-0016-008
Ref No Description Part No.
DC POWER CABLE AND HARDWARE KIT
PART NO. 023-9800-410 (10 Ft)
PART NO. 023-9800-422 (22 Ft)
A 001 Mic clip ground wire assembly 023-7171-911
EP101 Power connector contact (2) 515-9033-006
EP104 Ring term, 3/8” 10-12 AWG (1) 586-0001-019
EP105 Ring term, 3/4" 10-12 AWG (1) 586-0001-036
F 201 Fuse kit, 15A and 7A 534-0003-100
FH101 Fuseholder assembly
includes:
Body 534-1004-031
Knob w/washer 534-1004-032
Contact, 14-16 AWG (2) 534-1004-037
Spring 534-1004-035
HW201 Screw, 4-24 x 5/16"sheet metal (3) 575-3604-010
MP201 HD mic clip 023-3514-001
P 101 Power connector housing, dual 515-9033-012
W 101 Wire, 12 AWG stranded red 597-7021-202
W 103 Wire, 12 AWG stranded blue 597-7021-206
ACCESSORY WIRE KIT
PART NO. 023-9750-011
F 001 Fuse, 1A 250V FB AGC 534-0003-020
FH001 Fuseholder includes:
Fuse contact, 16-20 AWG (2) 586-9004-001
Body 534-1004-031
Knob 534-1004-032
Spring 534-1004-035
HW001 Crimp pin contact (7) 515-1501-055
P 100 Receptacle housing, 8-pin (2) 515-1501-050
AMPLIFIED DYNAMIC MICROPHONE
PART NO. 250-0740-300
C 001 3.3 µF 16V tantalum chip 510-2625-339
C 002 220 pF ±5% NPO 50V cer chip 510-3602-221
EP001 Contact .038" diameter 586-9008-100
EP002 Mic cord w/mod connector 597-2002-113
EP004 Terminal (on hanger) 022-0069-011
HW001 Screw 4-20 x 3/8 575-5604-012
HW004 Screw 2-56 x 3/8 575-1602-012
MK001 Dynamic mic cartridge 589-1011-003
MP001 Case front black 032-0426-100
MP002 Case back black 032-0427-100
Ref No Description Part No.