OX-10A/5A OXYGEN CONCENTRATOR OX-10A /5A Oxygen Concentrator Instruction Guide VERSION NO: VO Issued on 2016.3.10 WARNING-Read instruction guide before operating this equipment.
TABLE OF CONTENTS IMPORTANT SAFEGUARDS .......................................................................................................................................... 4 WHY YOUR PHYSICIAN PRESCRIBED SUPPLEMENTAL OXYGEN ...................................................................... 4 HOW YOUR OX-A SERIES OXYGEN CONCENTRATOR WORKS............................................................................ 4 IMPORTANT PARTS OF YOUR OXYGEN CONCENTRATOR .......................................
INDICATIONS FOR USE — The OX-A series Oxygen Concentrator is intended for use as an oxygen concentrator to provide supplemental low flow oxygen therapy in the home, nursing homes , patient care facilities, etc. WARNING Under certain circumstances, oxygen therapy can be hazardous. Seeking medical advice before using an oxygen concentrator is advisable.
IMPORTANT SAFEGUARDS Read this entire guide before using your OX-A series oxygen concentrator .Important information are highlighted by these terms throughout this guide: DANGER Urgent safety information for hazards that will cause serious injury or death. WARNING Important safety information for hazards that might cause serious injury. CAUTION NOTE Information for preventing damage to the product. Information which you should pay special attention.
IMPORTANT PARTS OF YOUR CONCENTRATOR Please take time to familiarize yourself with your OX-A series oxygen concentrator before operating. Before using this product, make sure you have the following items: 1 User manual. 1 Oxygen concentrator set. 1 Adapter-for connect Humidifier. 1 Oxygen Outlet Connector ． ． ． ． Front View (Figure 1) 1. Power Switch I =ON O=OFF 2. Circuit breaker – (selected units) resets the unit after electrical overload shutdown. 3. Humidifier Holder 4.
8/9 10 13 11 7 2 4 1BA 14 6 5 15 3 16 12 FRONT View (Figure 1) REAR View (Figure 2) SETTING UP YOUR OXYGEN CONCENTRATOR 1. Position your unit near an electrical outlet in the room where you spend most of your time. DANGER Keep the oxygen concentrator at least 5 feet (1.6 m) from hot, sparking objects or naked sources of flame. NOTE—Do not connect to an electrical outlet controlled by a wall switch. NO other appliances should be plugged into the wall outlet 2.
BEFORE OPERATING YOUR OXYGEN CONCENTRATOR 1. Before operating your unit always checks to be sure the air filter (located on the back of your unit) is existed .Proper replace of this filter is discussed in the Caring for Your Concentrator section on page 9. 2. Attach the appropriate oxygen accessories to the oxygen outlet. Oxygen Tubing Connection: a. Attach the oxygen tubing directly to the connector.(Figure 3) Figure 3 Oxygen Tubing Connection with Humidification: a.
Remove the power cord completely from the line cord strap, Make sure the power switch is in the “Off” position, and insert the plug into the wall outlet; the unit is double insulated to guard against electric shock. WARNING Improper use of the power cord and plugs can cause a burn, fire or other electric shock hazards .Do not use the unit if the power cord is damaged OPERATING YOUR OX-10A/5A OXYGEN CONCENTRATOR DANGER Oxygen causes rapid burning.
Before attempting any cleaning procedures, turn the unit “off.” Oxygen Humidifier (reusable bottles) If your physician has prescribed humidification, clean your humidifier bottle daily. Follow the instructions Supplied by the manufacturer, If no cleaning instructions were supplied, follow these steps 1. Wash the humidifier in a solution of hot water and dishwashing detergent. 2. Soak the humidifier in a solution of one part white vinegar to three parts hot water for 30 minutes.
Accessories The accessories below are approved for use with OX-A series Oxygen Concentrators: object/part No. manufacturer/ trademark type/model technical data mark(s) of conformity1) Bubble Humidifier(200 ml Capacity) Hsiner Co,.Ltd REF7100 ABS,PP CE 0434 Mask / Tubing Hsiner Co,.Ltd 30122 PVC CE 0434 Cannula w/ 2.1m(7 ft) Oxygen Tubing Hsiner Co,.Ltd (disposable) 3020 PVC CE 0434 Oxygen Tubing (disposable) 30200 PVC CE 0434 Hsiner Co,.
MINOR TROUBLESHOOTING Symptom A. Unit does not operate. Power light is off when the power switch is “on .”Audible alarm is pulsing and Service Required light is flashing. Possible Cause Remedy 1. Power cord not properly inserted into wall outlet. 2. No power at wall outlet. 3.Oxygen concentrator circuit breaker activated (selected units). 1. Air filter is blocked. 2. Exhaust is blocked. B. Unit operates; the Power light is on when the Power switch is “On”. Red Service Required light is illuminated.
SPECIFICATIONS No. Item Rating 1. Delivery Rate (Lower delivery rates available for 2 to10 LPM(OX-10A) low application) 0.5 to 5 LPM(OX-5A) 2. Outlet Pressure 8.5-13 psi ( 68.5-90 kpa )OX-10A 8.5±0.5psi ( 68.5 kpa )OX-5A 3. Electrical Rating 230 V, 50 Hz, 3.4A (Max.)OX-10A 1.4A (Max.)OX-5A 4. Oxygen Percentage 2~9 LPM 93%±3%,10 LPM 90%±3%(OX-10A) 0.5~5 LPM 93%±3%,(OX-5A) 5. Average oxygen concentration at 2 l/min: 93%±3% 6.
SYMBOL General warning, caution, risk of danger Please read the instructions carefully before operating the product. Type B applied part Class II equipment Manufacture’s serial number Authorized representative in the European community Date of manufacture Manufacture Waste Electrical and Electronic Equipment Directive 2002/96/EC (WEEE Directive) after over the valid term within 3 years, the machine should be treated on local law or regulation requirement. To avoid hurt users and pollute environment.
ELECTROMAGNETIC IMMUNITY Guidance and manufacturer’s declaration – electromagnetic immunity The OX-10A/5A OXYGEN CONCENTRATOR is intended for use in the electromagnetic environment specified below. The customer or the user of the OX-10A/5A OXYGEN CONCENTRATOR should assure that it is used in such an environment.
DECLARATION OF CONFORMITY Manufacturer: Oxytek Medical Technology Co., Ltd. ADDRESS: 10-2 , Guang Long Industrial Park, South 1st Rd, Chencun town, Shunde district, Foshan city, Guang Dong Province , China. Product Designation: Catalog Number: Oxygen Concentrator OX-10A /5A EC authorized representation CGI Business Trading and Consulting e.K Hans-Bethe-Str.1, 60438 Frankfurt am Main, Germany Tel：+49 -69 1752 6970 +49-1785 647380 Email: cgi-trading-consulting@hotmail.
