INSTALLER/ CONSUMER SAFETY INFORMATION PLEASE READ THIS MANUAL BEFORE INSTALLING AND USING APPLIANCE. WARNING! IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, AN ELECTRICAL SHOCK OR FIRE MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. Electric Fireplace Models: TBREF36, TBREF36NH FOR YOUR SAFETY SERVICE MUST BE PERFORMED BY A QUALIFIED SERVICE AGENCY. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
TBREF Electric Fireplace Table of Contents Please read the Installation & Operating Instructions before using this appliance. Thank you, and Congratulations on your purchase of a CFM Specialty Home Products Electric Fireplace. IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in possible electric shock, fire hazard, and/or injury, and will void the warranty. Installation Instructions General Information .....................
TBREF Electric Fireplace Installation Instructions General Information 1. Read all instructions before using this appliance. 2. This appliance is hot when in use. To avoid burns, do not let bare skin touch hot surfaces. If provided, use handles when moving this appliance. Keep combustible materials, such as furniture, pillows, bedding, papers, clothes and curtains at least 3 feet (1 m) from the front of this appliance.
TBREF Electric Fireplace Fireplace Dimensions M Rough Opening Depth 1/2" (13mm) H L 16 m m ) K Rough Opening Width 5/ 8" ( O Rough Opening Height N M 5/8" (16mm) Recessed Nailing Flange G E J B C 3���" (95mm) F D E 7�����" (192mm) 2�����" (60mm) A Fig. 1 Fireplace specifications and framing dimensions. Ref.
TBREF Electric Fireplace Mantels The height that a combustible mantel is fitted above the fireplace is dependent on the depth of the mantel. This also applies to the distance between the mantel leg (if fitted) and the fireplace. For correct mounting height and width, refer to Figure 2a and 2b. The distances and reference points are not affected by the fitting of a bay window front trim kit. Noncombustible mantels and legs may be installed at any height and width around the appliance.
TBREF Electric Fireplace Hearth Nail side-nailing flange A hearth is not mandatory; however, for aesthetic purposes, we recommend use of a noncombustible hearth that does not obstruct the air openings. Cold Climate Installation: To conform to applicable insulation codes, it is mandatory the outer walls be insulated when installing this unit against a non-insulated exterior wall or chase. Cabinet Installations FP549 Fig. 3 Adjustable drywall strip (nailing flange).
TBREF Electric Fireplace 8. Connect the ground wire from the wall switch to the wire grouping from the power supply and the ground stud in the junction box. 9. Make sure the red wire (L2) in the junction box has a closed end splice or a wire nut properly applied. 10.Ensure all connections are tight. Insert all wiring inside the junction box and secure the cover. 240 Volt Wall Switch Wiring Installation A qualified electrician must perform any electrical wiring of this appliance.
TBREF Electric Fireplace 120 Volt Unit Installation 1. Locate the switch under the logset on the left front corner of the unit. 2. Check the voltage selection switch position to ensure it is in the 120 Volt position. 3. Loosen the screws securing the junction box cover and remove the cover. 4. Remove knockouts in the box cover to use the cable clamp. 5. Pull out two (2) wires: black and white. 6. Connect the black wire from the unit to the L1 (black) from the power supply.
TBREF Electric Fireplace Screen Kit Installation 1. Remove the plastic bag from each screen. 2. Remove the four (4) metal clips, two (2) for each side of the fireplace opening. 3. Slide screen panels against sides of the fireplace opening. 4. Align each metal clip with the hole it was removed from, while at the same time, hooking the clip through the last wire of the screen. Snap clips into place. (Fig. 5) 5. Pull screens back and forth to ensure they work freely. (Clip) FP1041 Fig. 5 Clip installation.
TBREF Electric Fireplace Electrical Wiring Diagram with Heater and Integral Remote Control G 1 WHITE REAR 16 BLACK 13 RED 22 WHITE 4 4 BLACK FAN/HEATER MOTOR 5 T'S 14 BROWN 12 4 BLACK 2 2 3 4 5 6 3 COIL 25 RED 5 BLACK 7 3 FLAME MOTOR 9 BLACK 9 8 BLACK 20 WHITE 1a 3 BLACK 10 BLACK 23 WHITE 18 WHITE WHITE 7 BLACK BLACK N 1b 1 RED L2 2a 15 24 WHITE 19 WHITE BLACK 13 16 BLACK 1 21 WHITE 2b 2 2 WHITE 15 BLACK 6 RED 14 BROWN 16 12 BLACK L1 1 FRONT 11 RED 17
TBREF Electric Fireplace Electrical Wiring Diagram without Heater and Integral Remote Control G 2 7 WHITE MOTOR FLAME N 8 WHITE O 3 2 3 1 4 BLACK I 1 L1 3 BLACK 1 BLACK 6 WHITE BLACK WHITE 2 BLACK BLACK 5 WHITE WHITE 5 4 CFM Component Identification 1. Switch 2. Flame Motor 3. Light Bulb 4. Light Socket w/Wiring Assembly 5. Cable Tie Nylon 6" - 1¹⁄₈" Black 6. CFM Wire req'd FP1540 Fig. 7 Wiring diagram for models without heat.
TBREF Electric Fireplace Operating Instructions Control Panel The control compartment is located inside the fireplace behind the steel curtain near the left front corner. To access the controls, simply slide the steel curtain open. 1. ON/OFF Switch 1. ON/OFF Switch The ON/OFF switch is for supplying power to light effects of the fireplace. This switch is normally illuminated to indicate that there is electrical power to the unit. 2.
TBREF Electric Fireplace TBREF36, TBREF36NH 2 1 3 4 7 5 6 8 9 15 11 13 14 16 12 �� 20 17 CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice.
TBREF Electric Fireplace TBREF36, TBREF36NH Electric Fireplace (continued) Ref. Description TBREF36 TBREF36NH 1. Log Set Complete 10007423 10007423 2. Heater Element 10004584 -- 3. Motor, AC, w/Terminals 10004262 10004262 4. Rocker Switch (Illuminated) 10001393 10001393 5. Thermostat - Heater Control 10002987 -- 6. Fan w/Bracket Assembly 10004695 -- 7. Sensor, 230°F Manual Reset 10004720 -- 8. Knob - Heater Controls 10001639 -- 9.
1 YEAR WARRANTY TBREF Electric Fireplace For TEMCO FIREPLACE PRODUCTS Electric Fireplaces BASIC WARRANTY: CFM Specialty Home Products (hereinafter referred to collectively as the "Company") warrants that your new Majestic Fireplaces® fireplace is free from manufacturing and material defects for a period of one year from date of installation, subject to the following conditions and limitations. 1.
CFM Specialty Home Products 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.temcofireplaces.
