Vec010S manual 03/04 5/22/06 11:19 AM Page 1 VEC010INV START-IT® COMPACT ELITE™ JUMP-START SYSTEM Rechargeable DC Power Supply – 12 volt PORTABLE • CORDLESS • RECHARGEABLE OWNER’S MANUAL & WARRANTY INFORMATION THIS MANUAL CONTAINS IMPORTANT INFORMATION REGARDING SAFETY, OPERATION, MAINTENANCE AND STORAGE OF THIS PRODUCT. BEFORE USING, READ AND UNDERSTAND ALL CAUTIONS, WARNINGS, INSTRUCTIONS AND PRODUCT LABELS, PLUS YOUR VEHICLE’S BATTERY MANUFACTURER GUIDELINES.
Vec010S manual 03/04 5/22/06 11:19 AM Page 2 SAFETY INFORMATION Save these instructions Be sure to read and understand all WARNINGS and CAUTIONS before using this product. Please read this guide carefully before use to ensure optimum performance and avoid damage to the system or items that you are using it with. WARNINGS: WARNING STATEMENTS IDENTIFY CONDITIONS OR PRACTICES THAT MAY RESULT IN PERSONAL INJURY OR LOSS OF LIFE.
Vec010S manual 03/04 5/22/06 11:19 AM Page 3 FIRST AID: • SKIN: If battery acid comes in contact with skin, rinse immediately with water, then wash thoroughly with soap and water. If redness, pain, or irritation occurs, seek immediate medical attention. • EYES: If battery acid comes in contact with eyes, flush eyes immediately for a minimum of 15 minutes - seek immediate medical attention.
Vec010S manual 03/04 5/22/06 11:19 AM Page 4 CONTENTS 1. INTRODUCTION ..........................................................................5 2. 3. 4. 5. 1.1 FEATURES ..............................................................................5,6 1.2 START–IT COMPACT ELITE APPLICATIONS ................................6 USE AS JUMP-START SYSTEM ..................................................7 2.1 JUMP-START WARNINGS............................................................7 2.2 FIRST AID...
Vec010S manual 03/04 1. 5/22/06 11:19 AM Page 5 INTRODUCTION This product has a sealed lead acid battery that should be kept at full charge. Recharge before first use, immediately after each use, and every six months if not used. Failure to do this may reduce the battery life dramatically. Congratulations! You have just purchased one of the finest Jump-Starter and 12 volt DC Systems (VEC010S) on the market today.
Vec010S manual 03/04 5/22/06 11:19 AM Page 6 AC Recharge Port Located just below the 12 volt DC outlet, the AC port is also covered by a rubber cap. The AC recharge adapter’s barrel connector plugs into this port during recharge. LED Area Light Located on the center of the control panel, this twin LED area light will provide proper lighting while changing a tire or connecting the Compact Elite™ to a battery.
Vec010S manual 03/04 5/22/06 11:19 AM Page 7 2. USE AS A JUMP-START SYSTEM 2.1 JUMP-START WARNINGS 1. There is risk of explosive gas being released when batteries are improperly charged or discharged. Failure to follow instructions may cause property damage, explosion hazard, and/or personal injury. 2. Never smoke while jump-starting. 3. Only attempt to jump-start a vehicle or boat in a well ventilated area. 4.
Vec010S manual 03/04 5/22/06 11:19 AM Page 8 FIGURE 2 NEG CABLE AND CLAMP (BLACK) 2.3 POS CABLE AND CLAMP (RED) JUMP-START PROCEDURE 1. Turn OFF ignition and all accessories before making cable connections. 2. Make sure the Compact Elite’s power safety switch is turned OFF. 3. Observe jump-starting negative or positive ground system, as follows: Negative ground (negative battery terminal connected to chassis) - most common. 4. Connect positive (+) red clamp to vehicle’s positive battery terminal. 5.
Vec010S manual 03/04 4. 5/22/06 11:19 AM Page 9 CHARGING/RECHARGING Lead-acid batteries require routine maintenance to ensure a full charge and long battery life. All batteries lose energy from self-discharge over time and more rapidly when they are at higher temperatures. Therefore, batteries need periodic charging to replace energy lost through selfdischarge. When the unit is not in use, Vector recommends that the battery is recharged at least every 60 days.
Vec010S manual 03/04 5/22/06 11:19 AM Page 10 WARNING! Do Not DC Charge for more than 3 Hours Maximum. Do Not Leave Unattended while DC Charging. 5. MAINTENANCE/REPLACEMENT PARTS For replacement parts (bulbs, batteries, charging adapters, etc.), contact Vector Technical Support: (954) 584-4446 or toll free (866) 584-5504. There are no user serviceable parts inside the unit. Periodically, the cables and connectors should be inspected for damage, corrosion, dust, and dirt.
Vec010S manual 03/04 8. 5/22/06 11:19 AM Page 11 WARRANTY 2 YEAR LIMITED WARRANTY PROGRAM This limited warranty program is the only one that applies to this product, and it sets forth all the responsibilities of Vector Manufacturing, Ltd., regarding this product. There is no other warranty, other than those described herein. This Vector Manufacturing, Ltd.
1 YEAR LIMITED WARRANTY PROGRAM This limited warranty program is the only one that applies to this product, and it sets forth all the responsibilities of Vector Manufacturing, regarding this product. There is no other warranty, other than described herein. This Vector Manufacturing product is warranted, to the original purchaser only, to be free of defects in materials and workmanship for one year from the date of purchase without additional charge.
IMPORTANT SAFETY INSTRUCTIONS 1. 2. 3. 4. 5. 6. 7. Always use the inverter where there is adequate ventilation. Do not block ventilation slots. DO NOT use the inverter near flammable materials or in locations that may accumulate flammable fumes or gases. ALWAYS turn OFF the inverter by removing it from the DC accessory outlet when not in use. NEVER IMMERSE THE UNIT IN WATER (fresh or salt). DO NOT expose to extreme heat or flames.
OPERATION OF INVERTER 1. 2. 3. 4. 5. Insert the unit into the vehicle’s (or jump-starter’s) accessory outlet. Rotate the plug slightly to make sure there is good contact. A green LED light on the inverter will indicate a proper operation. If the inverter does not work, make sure the ignition/accessory switch is actually powering the accessory outlet. Some vehicles need the ignition switch turned on. Plug in the AC appliance.
The inverter is capable of running most chargers and transformers. It is also ideal for use with Vector 12 volt DC cordless, portable and rechargeable DC power supplies and jump-starter products. CAUTIONS (Rechargeable Devices) • Certain rechargeable devices are designed to be charged by plugging them directly into an AC receptacle. • These devices may damage the inverter or the charging circuit.
