Full Product Manual

Periodic Service
10-14
2. Replace hoses and tighten hose clamps
securely, if radiator hoses are swollen,
hardened or cracked. Replace hoses and
hose clamps every 2 years or earlier, if
checked and found that hoses are swollen,
hardened or cracked.
 Radiator hose  Clamp bands
 Precaution at Overheating
Take the following actions in the event the
coolant temperature is close to or more than the
boiling point, which is called “Overheating”.
1. Stop the vehicle operation in a safe place
and keep the engine unloaded idling.
2. Don’t stop the engine suddenly, but stop it
after about 5 minutes of unloaded idling.
3. Keep yourself well away from the vehicle for
at least 10 minutes or while the steam is
blowing out.
4. Check to see if there is no danger such as
burning, get rid of the causes of overheating
according to the “TROUBLESHOOTING”
section of the manual, and then start the
engine again.
■ Checking Intake Air Line
1. Check to see if the hoses and hose
2. clamps are tight and not damaged.
3. If hoses and clamps are found to be worn or
damaged, replace or repair them at once.
 Hose  Hose clamp
EVERY 300 HOURS
■ Checking Tire
1. Check to see if tires are not damaged.
2. If the tires are cracked, bulged, or cut, or
they are worn out, replace or repair them at
once.
 Tire Tread Depth
Always replace the tires when the tread depth is
worn to minimum allowable.
① 3mm(0.12in)