SDS

ManualsBrandsUSG Sheetrock Brand ManualsBuilding materials18 lb. Easy Sand 5 Lightweight Setting-Type Joint Compound

SAFETY DATA SHEET

1. Identification

SHEETROCK® Brand EASY SAND™ Lightweight Setting-Type Joint Compound, 5, 20, 45,

90, 210

Product identifier

Other means of identification

61000030002

SDS number

Joint Compound, Finishing Compound, Taping Compound, Mud

Synonyms

Interior use.

Recommended use

Use in accordance with manufacturer's recommendations.

Recommended restrictions

Manufacturer/Importer/Supplier/Distributor information

United States Gypsum Company

Company name

550 West Adams Street

Address

Chicago, Illinois 60661-3637

1-800-874-4968

Telephone

www.usg.com

Website

1-800-507-8899

Emergency phone number

2. Hazard(s) identification

Not classified.

Physical hazards

Category 1ACarcinogenicity (inhalation)

Health hazards

Category 2 (Lung)Specific target organ toxicity, repeated

exposure

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

May cause cancer by inhalation. May cause damage to organs (Lung) through prolonged or

repeated exposure.

Precautionary statement

Prevention

Obtain special instructions before use. Do not handle until all safety precautions have been read

and understood. Do not breathe dust. Wear protective gloves/protective clothing/eye

protection/face protection.

Response

If exposed or concerned: Get medical advice/attention.

Storage

Store locked up.

Disposal

Dispose of contents/container in accordance with local/regional/national/international regulations.

Hazard(s) not otherwise

classified (HNOC)

None known.

Supplemental information

None.

3. Composition/information on ingredients

Mixtures

CAS numbe

%Chemical name

26499-65-0Plaster of Paris (Calcium sulfate

hemihydrate CAS 10034-76-1)

< 60

1317-65-3 or 16389-88-1Limestone (calcium carbonate CAS

1317-65-3 or dolomitic CAS

16389-88-1)

< 50

SHEETROCK® Brand EASY SAND™ Lightweight Setting-Type Joint Compound, 5, 20, 45, 90, 210 SDS US

916564 Version #: 04 Revision date: 24-March-2021 Issue date: 31-December-2013

1 / 8

Summary of content (8 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Other means of identification SDS number Synonyms SHEETROCK® Brand EASY SAND™ Lightweight Setting-Type Joint Compound, 5, 20, 45, 90, 210 61000030002 Joint Compound, Finishing Compound, Taping Compound, Mud Recommended use Interior use. Recommended restrictions Use in accordance with manufacturer's recommendations.
PAGE 2
Chemical name CAS number % Attapulgite 12174-11-7 < 10 Perlite 93763-70-3 < 10 Calcium sulfate dihydrate 13397-24-5 <2 CAS number % 14808-60-7 < 1.5 Impurities Chemical name Common name and synonyms Crystalline silica (Quartz) Composition comments All concentrations are in percent by weight. Raw materials in this product contain respirable crystalline silica as an impurity. The weight percent of respirable crystalline silica found in this product is < 1.5%.
PAGE 3
Conditions for safe storage, including any incompatibilities Store in a cool, dry, well-ventilated place. Store away from incompatible materials. Avoid contact with acids, water, and moisture. 8. Exposure controls/personal protection Occupational exposure limits US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053) Impurities Type Crystalline silica (Quartz) (CAS 14808-60-7) TWA US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.
PAGE 4
US. NIOSH: Pocket Guide to Chemical Hazards Components Type Value Form Perlite (CAS 93763-70-3) 5 mg/m3 Respirable. 10 mg/m3 Total 5 mg/m3 Respirable. 10 mg/m3 Total TWA Plaster of Paris (Calcium sulfate hemihydrate CAS 10034-76-1) (CAS 26499-65-0) TWA Impurities Type Value Form Crystalline silica (Quartz) (CAS 14808-60-7) TWA 0.05 mg/m3 Respirable dust. Biological limit values No biological exposure limits noted for the ingredient(s).
PAGE 5
Relative density 0.6 - 0.7 (H2O=1) Solubility(ies) Solubility (water) Slightly. Partition coefficient (n-octanol/water) Not applicable. Auto-ignition temperature Not applicable. Decomposition temperature Not applicable. Viscosity Not applicable. Other information Bulk density 35 - 45 lb/ft³ VOC None detected. 10. Stability and reactivity Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport.
PAGE 6
Specific target organ toxicity single exposure No data available, but none expected. Specific target organ toxicity repeated exposure May cause damage to organs (lung) through prolonged or repeated exposure. Aspiration hazard Due to the physical form of the product it is not an aspiration hazard. Chronic effects Prolonged and routine inhalation of high levels of respirable crystalline silica particles can lead to the lung disease known as silicosis.
PAGE 7
SARA 304 Emergency release notification Not regulated. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053) Crystalline silica (Quartz) (CAS 14808-60-7) Cancer lung effects immune system effects kidney effects Toxic Substances Control Act (TSCA) All components on the TSCA 8(b) inventory are designated "active" or are exempt from reporting under the Inventory Update Rule. Superfund Amendments and Reauthorization Act of 1986 (SARA) SARA 302 Extremely hazardous substance Not listed.
PAGE 8
Crystalline silica (Quartz) (CAS 14808-60-7) International Inventories Country(s) or region Australia Inventory name Australian Inventory of Industrial Chemicals (AICIS) On inventory (yes/no)* No Canada Domestic Substances List (DSL) Canada Non-Domestic Substances List (NDSL) China Inventory of Existing Chemical Substances in China (IECSC) Europe European Inventory of Existing Commercial Chemical Substances (EINECS) No Europe European List of Notified Chemical Substances (ELINCS) No Japan In