Use and Care Manual

First Choice When Quality Matters
NORTH AMERICA
Plunger Pumps Operating Instructions and Parts Manual RC Series Pumps
2. Place the head evenly
onto the plungers and push it until it makes contact with the drive end of the pump. (See Figure 32)
3. Torque the head bolt as
shown in the tightening sequence diagram. (See Figure 33 & 34)
(See Table D
or parts breakdown)
OIL CHANGE Change oil after fi rst 50 hours of use. Then every 500 hours. Refer to parts breakdown for oil type. WINTER OR LONG TIME STORAGE 1. Drain all of the water out of the
pump.
2. Run a 50% solution of a RV or
non-toxic/biodegradable antifreeze through the pump.
3. Flush the pump with fresh water
before the next use.
4. In freezing conditions failure to
do this may cause internal pump damage.
5. For long periods of storage in
non-freezing areas the solution will keep the seals and O-rings lubricated.
Service Pumps (continued)
Figure 33
Figure 32
Figure 34
Plunger Pumps Operating Instructions and Parts Manual RC Series Pumps
First Choice When Quality Matters
NORTH AMERICA
Pos. Code Description Qty. Pos. Code Description Qty.
1 3200110 Plug (216 in/lbs) 6
2 120690 O-Ring 6 3 2769050 Complete valve
(92 in/lbs) 6
4 800410 Screw 8 5 1381550 Washer 8 6 3200020 Head 1 7 180101 O-Ring 1 8 820361 Plug
(354 in/lbs) 1
9 740290 O-Ring 1 10 1980740 Plug (221 in/lbs) 1 11 1780140 Ring 3 12 1780720 Gasket 3 13 3200130 Piston guide 3 14 3200142 Gasket 3 15 3200260 Ring 3 16 770260 O-Ring 3 17 3200120 Piston guide 3 18 3200010 Pump body 1 19 1780490 Bearing 1 20 1260790 Snap ring 2 21 1780550 Snap ring 1 22 395081 O-Ring 1 23 3200090 Disc 1 24 3200080 Oil indicator 1 25 3200070 Cover 1 26 1200430 Screw
(92 in/lbs) 8
27 880130 Oil cap 1 28 1260110 Nut (106 in/lbs) 3 29 1260100 Washer 3 30 1260210 Piston guide 3 31 1260091 Spacer 3 32 1260460 Seal 3 33 480480 O-Ring 3 34 3200060 Piston guide 3 35 3200040 Conrod 3 36 1780050 Conrod pin 3 37 2760280 O-Ring 1 38 3200030 Rear cover 1
39 820510 O-Ring 1 40 880581 Plug 1 41 3200220 Screw 4 44 3200290 Crankshaft
 1
44 3200270 Crankshaft  1 42 3200330 Key 1 43 2760350 Bearing 1 45 1260750 Seal 1 46 320210 Base 2 47 1322640 Washer 4 48 850250 Screw 4 AR64516 Oil 2 O
IL CAPACITY - 9.81 OZ
Legend
For  For  RC11.17 RC13.17