Installation Guide

UDECX RECOMMENDED USES:
UDECX is a portable, modular patio decking system intended to be installed by the DIY homeowner or contractor on grade.
UDECX should be installed on undisturbed soil. Loose surface soil, vegetation and grass should be removed to provide a firm
surface for the piers to rest upon.
UDECX may be installed over existing concrete slabs and patios to conceal cracks or simply improve the aesthetics.
The modular nature of UDECX allows for smaller or larger configurations than our 10’x10’ starter kit. For example, using fewer
pads to elevate trash cans or provide a base for air conditioning condensers. Using additional components creates expansion
opportunities that are only limited by the space you have available.
UDECX may be used to create walkways similar to sidewalks.
UDECX offers an optional 2” aluminum railing system. In most cases, a railing system is not required by code if the surface of
the deck is not over 20” above grade.
WARNINGS:
UDECX support piers need to be installed on undisturbed soil. This requires the removal of any vegetation including grass
and loose soil until undisturbed soil is reached.
UDECX support piers need to be secured to the ground through the use of spikes, as detailed in these instructions. Failure
to secure the UDECX system to the ground may result in the risk of uplift in areas and times of high winds. Check your
local codes to verify whether or not additional attachment is required.
When using 1” shims and 3” riser blocks, the anchoring spikes must pass through all components securing them together
and to the ground. When installing Shims or Risers 18” spikes are required.
The UDECX system should be inspected regularly for areas of settlement. Should this occur, these areas should be
disassembled, and the pier raised means of additional soil or UDECX shims and riser blocks until the desired height is
reached. Reinstall the surface pads, securing them with the cam locks.
Do not place fire pits, other than UDECX brand fire pits, on or near the UDECX system. The heat generated by a fire pit
may damage, diminish structural integrity and/or create a fire hazard.
The UDECX system is not intended to have the finish decking surface higher than 12” above the surrounding grade. No
combination of 1” shims and/or 3” riser blocks should be used to elevate the finished surface higher than 12”.
Building codes require guardrails when a decking surface exceeds 20” above adjacent grade, The UDECX optional railing
system is defined by the manufacturer as a guardrail. All piers on a UDECX installation that have a railing system installed
must be secured to grade with spikes.
Use caution in assembling the UDECX system to avoid pinch hazard when installing the surface pads.
Most jurisdictions will not require a building permit if your deck is below 30” and not permanently attached to your home,
and less than 300 square feet. Check with your local building department to verify whether or not a permit is required.
While a building permit may not be required, placement of your UDECX Patio Deck must be within setbacks of local zoning
codes. Verify with your local municipality what the required setbacks are from the side and rear of your property.
If the UDECX Patio Deck is installed against an existing home, and the finished surface of the system is within 18” of a
window sill, local codes may require the window to be safety glass.
Do not clean the UDECX system with abrasive or caustic cleaners as this may void the warranty of the components. The
UDECX system should be cleaned with mild detergent and water. Do not use a pressure washer to clean the surface, as
this may result in voiding the warranty.
HURRICANE & TORNADO ZONES: The UDECX Patio Deck must be secured with 12” or 18” Anchor Spikes, or other
anchoring methods deemed acceptable per region building codes. Check with code officials in your municipality to confirm
what anchoring requirements are necessary to comply with local building codes.
TOOLS NEEDED FOR ASSEMBLY:
Your Starter Kit includes a Cam Lock Tool for the assembly of your Portable Patio Deck, but you may need to supply the
following tools:
Hand Sledge or Hammer
4’ Level
Shovel or Spade
INDEX
Recommended Uses Page 2 Installation Instructions Page 6
Warnings Page 2 Installation Instructions Page 7
Tools Needed Page 2 Installation Instructions Page 8
Warranty Page 3 Leveling and Elevating Page 9
Assembly Overview Page 4 Railing Installation Page 10
Parts List Page 5 Railing Installation Page 11
2
23
NOTES