Turbo Air Speeds up the Pace of Innovation Open Display Merchandisers Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment. Horizontal Open Display Cases TOM-30L*-**-*-N TOM-40L*-**-*-N TOM-50L*-**-*-N TOM-60L*-**-*-N TOM-75L*-**-*-N TOM-30S*-**-*-N TOM-40S*-**-*-N TOM-50S*-**-*-N TOM-60S*-**-*-N TOM-75S*-**-*-N TOM-W-30S*-**-*-N TOM-W-40S*-**-*-N TOM-W-50S*-**-*-N TOM-W-60S*-**-*-N TOM-W-75S*-**-*-N www.turboairinc.
CONTENTS PAGE INTRODUCTION 10 SPECIFICATIONS 11 INSTALLATION Damage inspection 12 Location of display Leveling of display OPERATING INSTRUCTIONS 14 Power switch Light switch Temperature control Thermometer Placing the product MAINTENANCE & CLEANING 15 Condenser coil TROUBLESHOOTING 16 Merchandiser not functioning Merchandiser is warm Lights are not working WARRANTY NOTE 17 19~22
NOTICE • This equipment is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge unless they have been given supervision or instructions concerning the use of this equipment and the hazards involved by a person responsible for their safety.
FOR HYDROCARBON REFRIGERATION UNITS WARNING This unit uses R-290 (propane), or R-600a (isobutane) as a refrigerant. These hydrocarbon refrigerants are highly environmentally compatible but also are flammable and combustible. Please read this manuel thoroughly before installing and operating the unit. Please take cautious measures to avoid risk of fire or explosion. PLEASE REFER TO THE LABEL INSIDE THE CABINET TO CHECK REFRIGERATION TYPE AND VOLUME. DANGER - Risk of fire or explosion.
FOR HYDROCARBON REFRIGERATION UNITS WARNING • Handle the unit with care in order to avoid any serious damage to the refrigeration system. • The refrigerant tubing, condenser, and evaporator coils are easily prone to damage while handling, moving, installing, and cleaning the unit, which may lead to fire or even explosion. • Refrigerant squirting out of the pipes could ignite or cause an eye injury.
IMPORTANT SAFETY INFORMATION SAFETY PRECAUTIONS To avoid any risk of fire, explosion, electric shock, personal injury, material damage or incorrect use of the appliance, be sure to observe the following safety precautions. (After reading these owner’s manual instructions, please keep the manual booklet in a safe place for reference. Remember to hand it over to any subsequent owners) WARNING • The unit must be installed and located in accordance with the manufacturer’s installation instructions.
IMPORTANT SAFETY INFORMATION INSTALLATION & USAGE WARNING • Do not install the unit in a damp place where it could be splashed with water. Incorrect insulation of the electrical parts may cause fire or electric shock. • Do not plug several appliances into the same sockets. This could cause overheating and risk start of a fire. • Keep the power plug away from the rear of the cabinet. A damaged power plug may cause fire due to overheating.
IMPORTANT SAFETY INFORMATION INSTALLATION & USAGE CAUTION • There is a risk of death from suffocation if a child puts the packing materials on his or her head. • Do not store any articles on top of the appliance. Articles may fall while opening or closing the door, and could cause personal injury or material damage. • Do not store pharmaceutical products, scientific materials or other temperature-sensitive products in the refrigerator.
IMPORTANT SAFETY INFORMATION PROPER DISPOSAL OF OLD APPLIANCE For environmental purposes, refrigeration appliances must be disposed of properly. This applies to your old appliance, and at the end of its service life, for your new appliance as well. WARNING Before disposing of old appliances, make them inoperable. Remove plug from mains, severe the power cable, and remove or destroy any snap or latch closures.
INTRODUCTION This owner’s manual has important information. Please read the entire manual before installing your new Turbo Air Open Display Merchandiser. For specific questions not answered on this manual, please call: CUSTOMER SERVICE DEPARTMENT TURBO AIR 4184 E. Conant St. Long Beach, CA 90808 1-800-381-7770 Please write down the model and serial number of your merchandiser for future references: MODEL NUMBER SERIAL NUMBER WARNING Keep this manual in a safe place for your reference.
SPECIFICATIONS Model TOM-30L*-**-*-N Dimension (W x D x H) in. 28 x 34.6 x 46.1 39 x 34.6 x 46.1 6.7A 6.9A TOM-40L*-**-*-N TOM-50L*-**-*-N TOM-60L*-**-*-N TOM-75L*-**-*-N 50.8 x 34.6 x 46.1 63.2 x 34.6 x 46.1 75.6 x 34.6 x 46.1 Electricity Full Load Amperes Compressor 115V/1PH/60HZ NEK6210U 6.9A NEU6217U Refrigerant Lighting 2 X NEU6217U 9.5W X 2 Net Weight 12.6W X 2 257 lbs. 317 lbs. 376 lbs. Model TOM-30S*-**-*-N TOM-40S*-**-*-N TOM-50S*-**-*-N Dimension (W x D x H) in. 28 x 34.
INSTALLATION INSTRUCTIONS DAMAGE INSPECTION Prior to installation, the customer must check for damages with the freight company before the unit is accepted. 1. If the crate is damaged, make sure to note the damage on the Bill of Lading prior to signing the delivery off. 2. Concealed damage must be reported within 5 days of receiving the unit. Bill of Lading must be faxed to the Claims department. Pictures of both unit and crating may be requested.
Turbo Air Recommended Operating Conditions Units should not be placed in direct sunlight. Units should not be placed near HVAC vents. Units should not be placed near fans. DOOR LEVEL Level the cabinet on all four corners of the base. Units should not be placed near doorways. 12” 305mm 4“ 102mm Confirm there is enough clearance for proper air circulation 75℉ (23℃) and 55% humidity Operating environment not to exceed 75℉ (23℃) and 55% humidity.
OPERATING INSTRUCTIONS Level and set your merchandiser in place. Connect all necessary electrical connections. Your Open Display Merchandiser should now be ready for use. TOM-**L, TOM-**S • POWER SWITCH: Located at the bottom of front panel right, colored in red. • LIGHT SWITCH: Located at the bottom of front panel right, colored in green. • TEMPERATURE CONTROL: Located at the bottom of front panal right. TOM-W-**S • POWER SWITCH: Located at the bottom of rear panel right, colored in red.
MAINTENANCE & CLEANING Always turn off your unit (both power and lights) when cleaning. Remove all products and allow your unit to reach room temperature. Do not allow electrical components to get wet. CLEAN YOUR OPEN DISPLAY MERCHANDISER THOROUGHLY BEFORE FIRST USAGE. a. Do not clean with harsh detergents. Use mild soap. b. Remove all products. c. Remove shelves and bottom trays. d. Clean interior with warm water and mild detergent. e. Wipe with damp cloth. Do not leave soap residue.
TROUBLESHOOTING For any problems with your unit, please refer to the following check list. If you are still experiencing problems or have questions, please call the Customer Service line at 1-800-381-7770. Ⅰ. MERCHANDISER NOT FUNCTIONING a. Check to see that the breaker hasn’t tripped. b. Check that enough power is BEING supplied to the unit. c. Check that the power switch is on. Ⅱ. MERCHANDISER IS WARM a. Check the condenser to see if it is clean. b.
2
2
2
2
