User Manual

HEADER WILL NOT LATCH:
Check Pro X15 rails to make sure they are level. See Step 5.
Makesuretherearheadersealisnotcaughtbetweensiderail&rearheader.
Check position of side rails on truck bed, they may be positioned incorrectly. See Step 4.
Makesurecoverhaspropertension.SeeStep15.
THE COVER IS TOO TIGHT OR TOO LOOSE:
See Step 12 and 15.
SIDE RAILS TIP DOWNWARD OR UPWARD:
- Reposition clamp up or down, refer to step 5.
- In some cases, a small shim can be used to tip rails upward. Contact customer service for shim pack (1118036).
COVER LEAKS WATER:
- Cover is not designed to be fully water tight.
 -Makesureclampsaretightandrailsarepositionedcorrectly.
- Extra seal can be added to help block water intrusions.
TOP OF COVER POOLS WATER:
- Certain amount of water pooling is normal with fabric covers.
- The cross tubes are not arched, therefore some water pooling may occur and is normal. This will not affect perfrom-
ace or the water management properties in this fabric.
 -Makesurecoverispulledtightoneachsideandautomatictensioncontrol
is properly adjusted.
COVER ROLLS UP CROOKED:
 -Makesurecontrolstrapsareevenlyset.SeeStep13.
TROUBLESHOOTING
Questions?
Call our friendly customer service staff
Toll Free at:
1-877-878-9336
Mon-Fri8am-5pmCST
TROUBLESHOOTING FABRIC/ FABRIC CARE
1. Fabric top surface has wrinkles after rolling cover closed.
- Pull fabric taut from each side. For best results, the help of a second person pulling on the opposite side is
preferable.
2. Fabric top surface sags between cross tubes.
 -Adjustmenttoautomatictensioncontrolmayberequired,refertoStep15.
3. Wind lifts up edge of fabric.
 -Makesuretoengagehookandloopondriverandpassengersideafterclosingthecover.Thismayneedtobe
done periodically when taking long trips.
4. Excessive fabric utter while driving.
- Check fabric tension, refer to Step 15.
 -Makesurehookandloopfastenersareset,seestep12.
5. How to Clean Fabric.
 -Soap,water,andsoftnebristlebrush.
7