Manual

BRAKE ADJUSTMENT
If the tractor does not come to a complete stop when
the brake pedal is completely depressed, or if the
tractor's rear wheels can roll with the parking brake
applied, the brake is in need of adjustment.
The brake disc can be found on the right side of the
transmission in the rear of the tractor. Adjust if
necessary as follows:
• Looking at the brake disc from the right side of
the tractor, locate the compression spring and
brake disc.
• Loosen, but do NOT remove the hex nut
found on the right side of the brake assembly.
See Figure 14.
• Using a feeler gauge, set the gap between the
brake disc and the brake puck at .011".
• Re-tighten the hex nut loosened earlier.
Set Gap __-I _"_ _)// ""_J
at .011" /-_///_
Bra.eDisc/ y /
¢ Spring III/
NOTE: Viewshownfrombeneathtractor.
Figure 14
SECTION 10: MAINTENANCE
WARNING: Disconnect the spark plug
wire(s) and ground against the engine
before performing any adjustments, repairs
or maintenance.
ENGINE
Refer to the separate engine manual for engine
maintenance instructions.
Check engine oil level before each use as
instructed in the separate engine manual packed
with your unit. Read and fellow instructions
carefully.
Changing Engine Oil
• Unscrew oit fill cap and remove dipstick from
the oil fitl tube. See Figure 15.
Oil Fill Cap Protective Cap
Pop open the protective cap on the end of the
oil drain valve to expose the oil drain port. See
Figure 15.
Push oil drain hose (packed with unit) onto the
oil drain port. Route the opposite end of the
hose into an appropriate oil collection
container with a capacity great enough to
collect the used oil.
• Push the oil drain valve in slightly, then rotate
counterclockwise and pult outward to begin
draining oit. See Figure 15.
• Service the oil filter (if so equipped) as
instructed in the separate engine manual
packed with your unit.
Perform the above steps in the opposite order after
oit has finished draining.
• Refill the engine with oil.
IMPORTANT: Refill the engine with the proper
capacity and weight of motor oil as instructed in the
separate engine manual.
Oil Fill Tube Oil Drain Valve
Oil Drain Port
NOTE: Valve location will vary with engine style.
Figure 15
Service air cleaner every 25 hours under normal
conditions. Clean every few hours under extremely
dusty condition. To service the air cleaner, refer to
the separate engine manual packed with your unit.
The spark plug(s) should be cleaned and the gap
reset once a season. Spark plug replacement is
recommended at the start of each mowing season;
check engine manual for correct plug type and gap
specifications.
18