Instinct Installation Manual

TABLE OF CONTENTS
vi
9.5. Main Menu......................................................................................................................... 47
9.6. EZ Setup ........................................................................................................................... 47
9.7. Heating EZ Setup .............................................................................................................. 48
9.7.1 Select CH Demand (No outdoor sensor connected) .................................................. 48
9.7.2 Select CH Demand (Outdoor sensor connected) ...................................................... 49
9.8. Domestic Hot Water EZ Setup - INSTINCT Solo Units ................................................... 50
9.9. Domestic Hot Water EZ Setup - INSTINCT Combi Units ................................................ 51
9.10. Altitude Setup .................................................................................................................... 51
9.11. EZ Setup Reset ................................................................................................................. 52
9.12. Display EZ Setup
.................................................................................................................. 52
9.13. C H / DHW O p e r a t i on .............................................................................................................. 5 3
9.14. Boiler Information .............................................................................................................. 53
9.14.1 Information Items ................................................................................................ 54
9.14.2 Lockout Screen 55
9.14.3 Manual Reset Lockouts 56
9.14.4 Automatic Reset Blocking Lockouts ................................................................. 57
CHAPTER 10 - START-UP PREPARATION ................................................................ 59
10.1. Boiler System Fluid Requirements .................................................................................... 59
10.1.1 Boiler Fluid pH Level 6.0 to 8.0 ....................................................................... 59
10.1.2 Boiler Fluid Hardness Less Than 7 Grains ................................................................ 59
10.1.3 Chlorinated Water ........................................................................................ 59
10.1.4 Flush Boiler to Remove Sediment ................................................................... 59
10.1.5 Cleaning of Old Boiler/System ........................................................................ 59
10.1.6 Cleaning of New Boiler/System ...................................................................... 59
10.1.7 Check and Test Antifreeze ............................................................................. 60
10.1.8 Use of Antifreeze in the Boiler System ..................................................................... 60
10.2. Filling the Boiler System .....................................................................................................61
10.3. INSTINCT Combi Water Heater - Water Requirements ........................................................... 61
10.3.1 Filling the Domestic Circuit ............................................................................ 61
10.4. Check Low Water Cut-Off Device .......................................................................................61
10.5. Check For Gas Leaks ............................................................................................................. 62
10.6. Check Thermostat Circuit .......................................................................................... 62
10.7. Inspect Condensate Drain Assembly .................................................................................62
CHAPTER 11 - START-UP PROCEDURES .................................................................. 63