Operator's Manual

ManualsBrandsToro ManualsSprayersElectric Hose Reel Kit, 2014 Multi Pro WM Turf Sprayer

FormNo.3379-608RevB

ElectricHoseReelKit

MultiProWMTurfSprayer

ModelNo.41243—SerialNo.314000001andUp

Operator'sManual

Introduction

Readthismanualcarefullytolearnhowtooperateand

maintainyourproductproperly.Theinformationinthis

manualcanhelpyouandothersavoidinjuryandproduct

damage.AlthoughTorodesignsandproducessafeproducts,

youareresponsibleforoperatingtheproductproperlyand

safely.

YoumaycontactTorodirectlyatwww .Toro.comforproduct

andaccessoryinformation,helpndingadealer,ortoregister

yourproduct.

Wheneveryouneedservice,genuineToroparts,oradditional

information,contactanAuthorizedServiceDealerorToro

CustomerServiceandhavethemodelandserialnumbersof

yourproductready.

Figure1illustratesthelocationofthe

modelandserialnumbersontheproduct.

Figure1

1.Modelandserialnumberplate

ModelNo.

SerialNo.

WARNING

CALIFORNIA

Proposition65Warning

Thisproductcontainsachemicalorchemicals

knowntotheStateofCaliforniatocausecancer,

birthdefects,orreproductiveharm.

Useofthisproductmaycauseexposureto

chemicalsknowntotheStateofCalifornia

tocausecancer,birthdefects,orother

reproductiveharm.

Note:ThisproductcomplieswithallrelevantEuropean

directives;fordetails,pleaseseetheseparateproductspecic

DeclarationofConformity(DOC)sheet.

Determinetheleftandrightsidesofthemachinefromthe

normaloperatingposition.

Important:Teon®tapeisrequiredfortheinstallation

ofthiskit.Thetapeisusedtowrapthreadsofttings

beforeassembly.Threadsshouldbewrappedstarting

atthebaseandtravelingtothetipofttingtoensurea

waterproofseal.

Important:Youwillneedanon-petroleum-based

lubricant,suchasvegetableoil,toinstallthiskit.

Safety

Improperuseormaintenancebytheoperatoror

ownercanresultininjury.Toreducethepotential

forinjury,complywiththesesafetyinstructionsand

alwayspayattentiontothesafetyalertsymbol,which

meansCaution,Warning,orDanger—personalsafety

instruction.Failuretocomplywiththeinstructionmay

resultinpersonalinjuryordeath.

Readalsothesafetyandoperationinstructionsinthevehicle

Operator'sManual.

•Donotaimthehandsprayeratanypersonoranimal.

Fluidsunderhighpressurecanpenetrateskinandcause

severeinjury,possiblyresultinginamputationordeath.

Hotliquidsandchemicalscanalsocauseburnsorinjury.

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.Toro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3379-608*B

Summary of content (12 pages)

PAGE 1
Form No. 3379-608 Rev B Electric Hose Reel Kit Multi Pro WM Turf Sprayer Model No. 41243—Serial No. 314000001 and Up Operator's Manual WARNING Introduction Read this manual carefully to learn how to operate and maintain your product properly. The information in this manual can help you and others avoid injury and product damage. Although Toro designs and produces safe products, you are responsible for operating the product properly and safely. You may contact Toro directly at www.Toro.
PAGE 2
If any part of the body comes in contact with the spray stream, immediately consult a physician familiar with injected fluid injuries. CAUTION Chemicals are hazardous and can cause personal injury. • Do not place your hand or any other part of your body in front of the spray nozzle. • Read the directions on the chemical labels before handling the chemicals and follow all manufacturer recommendations and precautions. • Do not leave the equipment under pressure when you are not present.
PAGE 3
Setup Loose Parts Use the chart below to verify that all parts have been shipped. Procedure 1 2 3 4 5 Description Qty.
PAGE 4
1 Preparing the Machine No Parts Required Procedure 1. Ensure that the machine is empty of all fluids. Note: If chemicals have been used in the machine, flush the system thoroughly with clean water; refer to your vehicle Operator's Manual for instructions. Figure 2 2. Park the machine on a flat area, set the parking brake, stop the pump, stop the engine, and remove the ignition key. 3. Disconnect the negative battery terminal from the battery. 1. Shoulder bolt 3. Flange nut (5/16 inch) 2.
PAGE 5
3. Drop the swivel plate into the hole on the hose-reel base. 3 4. On the underside of the hose-reel frame, attach the thrust washer and snap ring to the post on the swivel plate (Figure 5).
PAGE 6
4 Installing the Control Valve Parts needed for this procedure: Figure 7 1. Flange nut (3/8 inch) 3. Short bolt (3/8 inch) 2. Small washer 8. Install the large washer and spring pin to the underside of the hose-reel frame (Figure 8). 1 Control valve 1 Pressure gauge 1 T-fitting 1 O-ring 4 Long bolts 1 Hose-reel supply hose 4 Hose clamp 1 Supply-hose valve 3 Cable tie 1 R-clamp Procedure 1. Disconnect the pressure transducer wire from the pressure-gauge port. 2.
PAGE 7
11. Secure the wire harness to the hose-reel supply hose using 3 cable ties. 12. From the top of the tank-supply hose, measure down 13 cm (5 inches) and cut the hose. 13. Connect the 2 hose ends to the supply hose valve using 2 hose clamps (Figure 12). Figure 10 1. Pressure gauge 3. T-fitting 2. Control valve 4. Pressure-gauge port Figure 12 1. Tank-supply hose 2. Supply-hose valve 5. Connect the T-fitting to the pressure-gauge port (Figure 10). 6.
PAGE 8
Operation WARNING Fluid under pressure can penetrate skin and cause injury. • Keep your body and hands away from nozzles that eject high-pressure fluid. • Do not aim the sprayer at any person or animal. • Make sure that all fluid hoses and lines are in good condition and that all connections and fittings are tight before applying pressure to the system. • Use cardboard or paper to find leaks. • Safely relieve all pressure in the system before performing any work on it.
PAGE 9
routine (refer to your sprayer Operator's Manual). Failure to properly clean the spray gun may degrade the performance and reliability of the hose reel kit and spray gun. 6. Set the engine to the desired speed, then engage the neutral engine-speed lock. Important: Do not use a pressure setting higher than 1034 kPa (150 psi) with the hand sprayer. 7. Use the rate switch to set the desired pressure. Spraying with the Hand Sprayer 1. Pull out the desired amount of hose from the reel.
PAGE 10
Notes: 10
PAGE 11
Notes: 11
PAGE 12
The Toro Total Coverage Guarantee A Limited Warranty Conditions and Products Covered The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly warrant your Toro Commercial product (“Product”) to be free from defects in materials or workmanship for two years or 1500 operational hours*, whichever occurs first. This warranty is applicable to all products with the exception of Aerators (refer to separate warranty statements for these products).