Installation Instructions

ManualsBrandsToro ManualsSprayersElectric Hose Reel Kit, 2015 and After Multi Pro 1750 Turf Sprayer

FormNo.3391-209RevA

ElectricHoseReelKit

2015andAfterMultiPro

1750TurfSprayer

ModelNo.41159—SerialNo.315000001andUp

Operator'sManual

Introduction

Readthismanualcarefullytolearnhowtooperateand

maintainyourproductproperly.Theinformationinthis

manualcanhelpyouandothersavoidinjuryandproduct

damage.AlthoughTorodesignsandproducessafeproducts,

youareresponsibleforoperatingtheproductproperlyand

safely.

YoumaycontactTorodirectlyatwww .Toro.comforproduct

safetyandoperationtrainingmaterials,accessoryinformation,

helpndingadealer,ortoregisteryourproduct.

Wheneveryouneedservice,genuineToroparts,oradditional

information,contactanAuthorizedServiceDealerorToro

CustomerServiceandhavethemodelandserialnumbersof

yourproductready.Figure1illustratesthelocationofthe

modelandserialnumbersontheproduct.

Figure1

1.Modelandserialnumberplate

ModelNo.

SerialNo.

WARNING

CALIFORNIA

Proposition65Warning

Thisproductcontainsachemicalorchemicals

knowntotheStateofCaliforniatocausecancer,

birthdefects,orreproductiveharm.

Useofthisproductmaycauseexposureto

chemicalsknowntotheStateofCalifornia

tocausecancer,birthdefects,orother

reproductiveharm.

Note:ThisproductcomplieswithallrelevantEuropean

directives.Fordetails,pleaseseetheDeclarationof

Incorporation(DOI)atthebackofthispublication.

Determinetheleftandrightsidesofthemachinefromthe

normaloperatingposition.

Important:Teontapeisrequiredfortheinstallation

ofthiskit.Thetapeisusedtowrapthreadsofttings

beforeassembly.Threadsshouldbewrappedstarting

atthebaseandtravelingtothetipofttingtoensurea

waterproofseal.

Important:Anon-petroleumbasedlubricant,suchas

vegetableoil,willberequiredfortheinstallationofthis

kit.

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.T oro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3391-209*A

Summary of content (12 pages)

PAGE 1
Form No. 3391-209 Rev A Electric Hose Reel Kit 2015 and After Multi Pro® 1750 Turf Sprayer Model No. 41159—Serial No. 315000001 and Up Operator's Manual WARNING Introduction Read this manual carefully to learn how to operate and maintain your product properly. The information in this manual can help you and others avoid injury and product damage. Although Toro designs and produces safe products, you are responsible for operating the product properly and safely. You may contact Toro directly at www.Toro.
PAGE 2
Safety Improper use or maintenance by the operator or owner can result in injury. To reduce the potential for injury, comply with these safety instructions and always pay attention to the safety alert symbol, which means Caution, Warning, or Danger—personal safety instruction. Failure to comply with the instruction may result in personal injury or death. Read also the safety and operation instructions in the vehicle Operator's Manual. • Do not aim the hand sprayer at any person or animal.
PAGE 3
Setup Loose Parts Use the chart below to verify that all parts have been shipped. Procedure 1 2 3 4 5 Description Qty.
PAGE 4
5. Route the hose reel end of the wiring harness through the R-clamp as shown in Figure 2. 1 Preparing the Machine No Parts Required Procedure 1. Ensure that the machine is empty of all fluids. If chemicals have been used in the machine, flush the system thoroughly with clean water; refer to your vehicle Operator's Manual for instructions. Figure 2 1. R-clamp 2. Park the machine on a flat area, set the parking brake, stop the pump, stop the engine, and remove the ignition key. 2. Wiring harness 6.
PAGE 5
12. Connect the far end of the wiring harness to the fuse block ground (Figure 3). 3 Mounting the Hose Reel Parts needed for this procedure: 1 Hose-reel frame 10 Bolt (5/16) 10 Flange nut (5/16 inch) 1 Swivel plate 1 Hose reel 4 Large carriage bolt 4 Flange nut (3/8 inch) 1 Handle 1 Mud shield 1 Spring clip 2 Locknut 2 Small carriage bolt 2 Large R-clamp 1 Spray gun bracket 2 Spacer 2 Self-tapping screws 1 Thrust washer 1 Snap ring Figure 4 1. Hose-reel frame 2.
PAGE 6
Figure 6 1. Snap ring 2. Thrust washer 5. Loosely mount the handle to the swivel plate with 4 bolts (5/16 inch) (Figure 7). Figure 8 1. Bolt (5/16 inch) 4. Large R-clamp 2. Spray gun bracket 5. Flange nut (5/16 inch) 3. Spacer 6. Self-tapping screw 8. Attach the spray gun holder to the mud shield as shown in Figure 8. 9. Connect the wiring harness to the hose reel. Figure 7 1. Bolts (5/16) 3. Handle 2. Mud shield 6.
PAGE 7
4 Installing the Control Valve Parts needed for this procedure: 1 Control valve 1 Hose-reel supply hose 1 Gasket clamp 1 Straight hosebarb 1 Shut-off valve 1 Female cap 1 Fitting Figure 10 Procedure 4. Note the current left and right knob settings. 1. Remove the retainer that secures the a actuator to the manifold valve for the section valve or agitation valve (Figure 9). 5. Rotate the boom bypass valve cluster 180 degrees as shown in Figure 11.
PAGE 8
Note: If the Tank Cleanse Rinse Kit is installed, route the hose behind the rinse pump. Figure 12 1. Female cap 2. Shut-off valve 8. Disconnect the cap and coupler from the pressure-gauge port (Figure 13). Figure 14 1. Tank-supply hose 2. Hose-reel supply hose 14. Cable tie the wiring harness to the supply hose using 2 cable ties. Figure 13 1. Gasket 4. Coupler 2. 90-degree fitting 5. Control valve 3. Gasket clamp 6. Hose-reel supply hose 9.
PAGE 9
5. Press the hose wind button, and carefully guide the hose onto the reel moving the hose from side to side to evenly distribute the hose. 5 CAUTION Connecting the Spray Hose Hands, loose clothing, long hair, and jewelry could get caught in the hose and reel while rewinding and cause injury. Parts needed for this procedure: 1 Long hose with fitting 1 Spray gun 1 Plastic hose clamp, small • Keep your hands clear of the reel and hose while it is rewinding.
PAGE 10
Switching from Boom Spray Mode to Hand Spray Mode CAUTION Hands, loose clothing, long hair, and jewelry could get caught in the hose and reel while rewinding and cause injury. 1. Stop the machine, turn the booms off, and set the parking brake. • Keep your hands clear of the reel and hose while it is rewinding. WARNING Driving while using the hand sprayer can cause loss of control, resulting in injury or death. Do not operate the hand sprayer while driving.
PAGE 11
Declaration of Incorporation The Toro Company, 8111 Lyndale Ave. South, Bloomington, MN, USA declares that the following unit(s) conform(s) to the directives listed, when installed in accordance with the accompanying instructions onto certain Toro models as indicated on the relevant Declarations of Conformity. Model No. 41159 Serial No.
PAGE 12
Toro General Commercial Product Warranty A Two-Year Limited Warranty Conditions and Products Covered The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly warrant your Toro Commercial product (“Product”) to be free from defects in materials or workmanship for two years or 1500 operational hours*, whichever occurs first. This warranty is applicable to all products with the exception of Aerators (refer to separate warranty statements for these products).