Installation Instructions

ManualsBrandsToro ManualsAttachmentsNorth American Cab Light Kit, 2015 and After Groundsmaster 360 4-Wheel Drive Multi Purpose Machine and Groundsmaster 3280 Series Cab

FormNo.3437-283RevA

NorthAmericanCabLightKit

2015andAfterGroundsmaster

3604-WheelDriveMultiPurpose

MachineandGroundsmaster

3280SeriesCab

ModelNo.30701

InstallationInstructions

Installation

PreparingtheMachine

NoPartsRequired

Procedure

1.Parkthemachineonalevelsurface.

2.Engagetheparkingbrake.

3.Shutofftheengineandremovethekeyfromthe

ignitionswitch.

4.Removethenegativebatterycablefromthe

battery.

InstallingtheHeadlights

Partsneededforthisprocedure:

Flange-headbolt(3/8x1inch)

Flangelocknut(3/8inch)

Washer(3/8inch)

2Mountingbracket

2Headlightassembly

Procedure

1.Removethehardwarefromthelight(Figure1).

2.Discardtheexistingbracketandhardware

showninFigure1.

3.Installthenewbracketwiththehardwarefrom

thelight(Figure1).

4.Installthelightstothemachineasshownin

Figure1.

g310011

Figure1

Groundsmaster360machineshown

1.Headlight

5.Bolt(3/8x1inch)

2.Flatwasher(3/8inch)

6.Usethishardwarewiththe

light.

3.Flangenut(3/8inch)

7.Mountingbracket

4.Shortharness

8.Discardthishardware

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.T oro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3437-283*A

Summary of content (8 pages)

PAGE 1
Form No. 3437-283 Rev A North American Cab Light Kit 2015 and After Groundsmaster® 360 4-Wheel Drive Multi Purpose Machine and Groundsmaster® 3280 Series Cab Model No. 30701 Installation Instructions Installation 1 Preparing the Machine No Parts Required Procedure 1. 2. 3. Park the machine on a level surface. Engage the parking brake. Shut off the engine and remove the key from the ignition switch. Remove the negative battery cable from the battery. 4.
PAGE 2
Installing the Front Warning Lights 3 1. Remove the front warning light covers. 2. Apply the front light gasket to the front warning light (Figure 3). Installing the Warning Lights Parts needed for this procedure: 2 Front warning light 2 Front light gasket 4 Long bolt 4 Small washer 4 Flange nut (#10) 2 Rear warning light 2 Rear light gasket 4 Large washer g193413 Figure 3 1. Front light gasket 3.
PAGE 3
Installing the Rear Warning Lights 1. Remove the rear warning light covers. 2. Apply the rear light gasket to the rear warning light (Figure 5). 4 Installing the Controls Parts needed for this procedure: 2 Fuse (10 A) 1 Light-switch panel 1 Control knob 1 Rotary switch 1 Locknut (7/16 inch) 1 2-position switch 1 2-position switch (with light) 1 3-position switch 4 Short bolts 4 Small washers g193415 Figure 5 1. Rear light gasket 3. 2.
PAGE 4
g028664 Figure 8 1. Fuse-compartment cover 3. Short bolts 2. Fuse 4. Remove the fuse-compartment cover and install the 2 fuses (Figure 8). 5. Install the fuse-compartment cover. 5 Installing the Wire Harness Parts needed for this procedure: 1 Wire harness 1 Dual-rate flasher Procedure 1. Route the wire harness as shown in Figure 9. g028665 Figure 9 1. Dual-rate flasher 4 2. Route the power hookup down the right, rear cab post and connect it to the main wire harness on the machine. 3.
PAGE 5
6 Applying the Decals Parts needed for this procedure: 1 Warning decal 2 Yellow reflective tape 4 Red reflective tape Procedure 1. Apply the warning decal to the rear window of the machine (Figure 10 or Figure 11). g028667 Figure 11 GM3280 1. Warning decal 2. 2. Red reflective tape Apply the yellow reflective tape as shown in Figure 12. Note: Apply the yellow reflective tape on the corner of the frame so that it wraps from the front to the side. g028666 Figure 10 GM360 1. Warning decal 2.
PAGE 6
Operation 7 Operating the Cab Lights Completing the Installation Refer to Figure 13 for operating the cab lights. No Parts Required Procedure 1. Secure the front edge of the roof to the headliner using the previously removed small fastener. 2. Secure the cab roof to the headliner using the previously removed 4 nuts, washers, and bushings. 3. Install the negative battery cable to the battery. g028669 Figure 13 6 1. Lights—OFF position 6. Hazard lights—ON position 2. Headlights—ON position 7.
PAGE 7
Notes:
PAGE 8