Form No. 3432-585 Rev A Cement Bowl Compact Tool Carrier with Auger Head Attachment Model No. 22442—Serial No. 319000001 and Up Register at www.Toro.com.
Important: With your mobile device, you can scan the QR code on the serial number decal (if equipped) to access warranty, parts, and other product information. WARNING CALIFORNIA Proposition 65 Warning Use of this product may cause exposure to chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. Introduction The cement bowl attachment designed for use on Toro compact tool carriers with an Auger Head attachment to mix and pour up to 90.
Contents Safety Safety ....................................................................... 3 General Safety ................................................... 3 Slope Safety ....................................................... 4 Cement Bowl Safety ........................................... 4 Maintenance and Storage Safety........................ 5 Safety and Instructional Decals .......................... 5 Setup ........................................................................
– Drop-offs Improperly using or maintaining this machine can result in injury. To reduce the potential for injury, comply with these safety instructions and always pay attention to the safety-alert symbol , which means Caution, Warning, or Danger—personal safety instruction. Failure to comply with these instructions may result in personal injury or death. – Ditches – Embankments – Bodies of water The machine could suddenly roll over if a track goes over the edge or the edge caves in.
Maintenance and Storage Safety • Check fasteners at frequent intervals for proper tightness to ensure that the equipment is in safe operating condition. • Refer to the Operator’s Manual for important details if you store the attachment for an extended period of time • Maintain or replace safety and instruction labels, as necessary. Safety and Instructional Decals Safety decals and instructions are easily visible to the operator and are located near any area of potential danger.
Setup 1 Preparing the Machine No Parts Required Procedure 1. Park the machine on a level surface and engage the parking brake (if applicable). 2. Raise the loader arms so that the drive head clears the ground. 3. Shut off the engine and remove the key. g004516 Figure 3 1. Drive head 2. Cradle arm 2 Installing the Cement Bowl onto the Auger Drive Head 3. Bolt and nut 2. Start the engine. 3. Maneuver the drive shaft into the collar on the back of the bowl (Figure 2).
Product Overview Operation Specifications Mixing and Pouring Concrete Note: Specifications and design are subject to change without notice. Width 64 cm (25 inches) Length 46 cm (18 inches) Weight 34 kg (75 lb) Maximum dry concrete load 91 kg (200 lb) CAUTION When full of concrete, the bowl is very heavy and could unbalance the traction unit. The traction unit could tip, seriously injuring you or bystanders.
Transport Position Storage When transporting the attachment, keep it as close to the ground as possible, no more than 15 cm (6 inches) above the ground. Tilt it rearward. g292004 Figure 6 1. No more than 15 cm (6 inches) above the ground 2. Tilt the attachment rearward. 8 1. Before long-term storage, wash the attachment with mild detergent and water to remove dirt and grime. 2. Paint all scratched or bare metal surfaces. Paint is available from your Authorized Service Dealer. 3.
Notes:
Declaration of Incorporation Model No. 22442 Serial No. Product Description Invoice Description General Description Directive 319000001 and Up Cement Bowl, Compact Tool Carrier SWS CEMENT BOWL CE Compact Tool Carrier 2006/42/EC Relevant technical documentation has been compiled as required per Part B of Annex VII of 2006/42/EC. We will undertake to transmit, in response to requests by national authorities, relevant information on this partly completed machinery.
EEA/UK Privacy Notice Toro’s Use of Your Personal Information The Toro Company (“Toro”) respects your privacy. When you purchase our products, we may collect certain personal information about you, either directly from you or through your local Toro company or dealer.
California Proposition 65 Warning Information What is this warning? You may see a product for sale that has a warning label like the following: WARNING: Cancer and Reproductive Harm—www.p65Warnings.ca.gov. What is Prop 65? Prop 65 applies to any company operating in California, selling products in California, or manufacturing products that may be sold in or brought into California.
