TPC90 Operations Manual

NOTICE: Check the oil level in the engine and exciter. Engine and compactor warranties are VOID if this unit is
run without oil. Note: the Honda engine is built with a low oil sensor switch if the oil level is not adequate the
engine may not start. Before using each time check the oil level.
3. Turn the engine’s ON/OFF switch clockwise to the “ON” position.
4. Set the throttle to the idle position by moving the throttle lever fully to the right. Do not start the engine
on full throttle, as the compactor will vibrate as soon as the engine starts.
5. Taking a rm hold of the control handle with one hand, grasp the recoil starter handle with the other. Pull
the recoil starter until engine resistance is felt, then let starter return.
6. Taking care not to pull the starter’s cord fully out, pull the starter handle briskly.
7. Repeat until the engine res.
8. Once the engine res gradually, set the choke lever to the OFF position by moving it to the right.
9. If the engine fails to re after several attempts, recheck fuel level to make sure they are adequate and then
refer to trouble-shooting guide.
10. To stop the engine, set the throttle to idle and turn the engine ON /OFF switch counter-clockwise to the
“OFF” position.
11. Turn the fuel valve o.
2.4 To Start
1. Open the fuel cap by moving the fuel ON/OFF lever fully to the right.
2. If starting the engine from cold, set the choke to ON by moving the
choke lever fully to the left. If restarting a warm engine, the choke is
usually not required.
However, if the engine has cooled to a degree, partial choke may be
required.
11