OPERATOR PRECAUTIONS 1. This product emits carbon monoxide, an invisible and odorless toxin. Do not run this product indoors at any time. 2. Always turn engine off before adding fuel to the tank. 3. To avoid electrocution, do not touch the cap of the spark plug or wiring while the engine is on. 4. Do not touch the surface of the muffler and cylinder while the engine is running. It is extremely hot. 5. Do not spill pesticide or chemicals when filling or emptying tank. 6.
WARNINGS This is concrete sprayer is meant for use with water-based or waterborne compounds only. Do not spray solvent-based or explosive liquids with this sprayer. Failure to comply may cause serious bodily harm or death. Do not spray in the direction of others, as the pressure of this sprayer can blow small objects at great speed. Toxic exhaust fumes may be colorless and odorless and contain unburned hydrocarbons and benzol.
Check for leakage. To reduce the risk of serious or fatal burn injuries, do not start or run the engine until the leak is fixed. After fueling, tighten down the screw-type fuel cap as tight as possible. This reduces the risk of unit vibrations causing the fuel cap to loosen or come off and spill fuel. CONCRETE SPRAYER OPERATION Fueling x This engine is certified to operate on unleaded gasoline and two-stroke engine oil at a mix ratio of 50:1.
Starting Your Engine When starting the engine make sure the engine is fueled and the solution tank is prepped for spraying. 1. 2. 3. 4. 5. Move the choke to the closed position. Prime the engine 4-5 times, or until fuel is visibly passing through the fuel lines. Pull the recoil starter until the engine fires. After the engine starts, slowly move the choke to the open position. Let the engine idle for several minutes and then begin operation. Stopping Your Engine 1.
Dolly Mobility and Maneuverability For even greater mobility around job sites and concrete finishing projects, the Tomahawk Power Concrete Sprayer can be easily strapped to a dolly. For dolly availability, pricing, and installation reach out to a Tomahawk Power representative at www.tomahawk-power.com or call (866) 577-4476 for more information.
TECHNICAL SPECIFICATIONS Brand Model Engine Type Engine Power Tank Capacity Water Absorption Volume Working Pressure Fuel Type Start Type Dimensions Net Weight Tomahawk Power TPS25C 2 Stroke 1.8 HP 6.6 Gallons 1.
TROUBLESHOOTING Engine Troubleshooting Guide 9
Troubleshooting for Spraying 10
SPRAYER CLEANING AND STORAGE Sprayer Cleaning Immediately after each use of your Tomahawk Concrete Sprayer it is important to clean it properly. Fill the solution tank of the sprayer with 2-3 gallons of water. Start the engine and proceed to spray the water into a waste receptacle. Routine cleaning will help to clean out the sprayer’s pump, hoses, and spraying attachments – while reducing the chances of the system clogging. DO NOT use Xylene or any explosive chemical in the cleaning process.
PROPOSITION 65 EPA WARRANTY CALIFORNIA AND FEDERAL EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board, the United States Environmental Protection Agency and Tomahawk Power, LLC are pleased to explain the emissions control system warranty on your 2018-2019 small engine/equipment (SORE). In the United States and California, new small engine/equipment must be designed, built and equipped to meet the State's stringent anti-smog standards.
As the small engine/equipment owner, you should however be aware that Tomahawk Power, LLC may deny your warranty coverage if your small engine/equipment or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications. You are responsible for presenting your small engine/equipment to distribution center or service center authorized by Tomahawk Power, LLC as soon as the problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days.
(9)Any replacement part may be used in the performance of any warranty maintenance or repairs and must be provided without charge to the owner. Such use will not reduce the warranty obligations of Tomahawk Power, LLC (10)Add-on or modified parts that are not exempted by the Air Resources Board may not be used. The use of any non-exempted add-on or modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims.
(b) Hoses, belts, connectors, and assemblies.
TOMAHAWK WARRANTY LIMITED WARRANTY STATEMENT The Tomahawk Power TPS25C Concrete Sprayer is warranted to the original purchaser to be free from defects in material and workmanship from the date of purchase for the time periods listed as follows: 1 Year for Commercial Use Any part of the TPS25C Concrete Sprayer found to be defective within the applicable warranty period shall, at Tomahawk Power’s option, be repaired or replaced without charge.
Tomahawk Power, LLC San Diego, CA Sales Support (866) 577-4476 sales@tomahawk-power.com Service and Registration support@tomahawk-power.com www.tomahawk-power.
